Abstract:Due to the rich reserves of the raw materials, along with their low cost and nontoxic nature, Mg2Si1−xSnx-based compounds have generated intense attention from the international thermoelectric community for their application in thermoelectric power generation within the intermediate temperature range. In this work, we have adopted a two-step solid state reaction followed by a spark plasma sintering process to prepare a series of Sb-doped Mg2.16(Si0.4Sn0.6)1−ySby (0 ≤ y ≤ 0.055) solid solutions. We discuss the influence of Sb doping and the microstructure on the thermoelectric properties. Our results confirm that Sb acts as an effective n-type dopant and we estimate the maximum amount of Sb the Mg2Si0.4Sn0.6 structure can accommodate to be ∼2.3% by XRD, DSC and EPMA analyses. The electron transport properties and low-temperature electronic heat capacity measurements reveal that both the light conduction band and the heavy conduction band contribute to the transport in n-type Mg2Si0.4Sn0.6 solid solutions. The highest density-of-states effective mass and power factor were observed for Mg2.16(Si0.4Sn0.6)0.985Sb0.015 with an electron concentration of n ≈ 1.67 × 1020 cm−3, which is likely to be due to the Fermi level positioned within ∼2kBT of both the heavy and light conduction bands providing contributions from both bands. In addition, doping with Sb does not seem to affect the lattice thermal conductivity above room temperature. TEM analysis indicates the presence of Sn-rich precipitates with the size of several tens of nanometers dispersed in the Mg2Si0.4Sn0.6 matrix. Such a nanophase may enhance the boundary scattering of phonons and contribute to a low lattice thermal conductivity. Owing to the above characteristics of the band structure and the microstructure, the Mg2.16(Si0.4Sn0.6)0.985Sb0.015 solid solution with n = 1.67 × 1020 cm−3 possessed excellent thermoelectric properties and achieved a high ZT value of 1.3 at 740 K. Further reductions in the lattice thermal conductivity could be achieved via optimization of the nanophase inclusions, leading to a further enhancement of the figure of merit for Mg2Si0.4Sn0.6-based solid solutions.

Enhanced Thermoelectric Performance of Mg2si0.4sn0.6 Solid Solutions by in Nanostructures and Minute Bi-Doping

Tunable microstructures and improved thermoelectric performance of Mg 2(Si0.4-xSbxSn0.6) solid solutions

High figure of merit and thermoelectric properties of Bi-doped Mg 2Si0.4Sn0.6 solid solutions

Multiscale microstructures and improved thermoelectric performance of Mg 2 ( Si 0.4 Sn 0.6 ) Sb x solid solutions

High figure of merit and thermoelectric properties of Bi-doped Mg2Si0. 4Sn0. 6 solid solutions

Enhanced thermoelectric properties of Mg2Si 0.58Sn0.42 compounds by Bi doping

Enhanced thermoelectric performance of Sb-doped Mg2Si0.4Sn0.6 via doping, alloying and nanoprecipitation

Enhanced thermoelectric properties of Mg2Si0.3Sn0.7 via Bi-doping under high pressure

Optimized Nanostructure and Thermoelectric Performances of Mg2(Si0.4Sn0.6)Sbx Solid Solutions by in Situ Nanophase Generation

Enhanced Thermoelectric Properties of N-Type Mg2.16(Si0.4Sn0.6)1−ySby Due to Nano-Sized Sn-rich Precipitates and an Optimized Electron Concentration

Enhancing the Zt Value of Bi-Doped Mg2Si0.6Sn0.4 Materials Through Reduction of Bipolar Thermal Conductivity.

Effect of Sb Doping on the Thermoelectric Properties of Mg 2 Si 0.7 Sn 0.3 Solid Solutions

Effect of Sb Doping on the Thermoelectric Properties of Mg<sub>2</sub>Si<sub>0.7</sub>Sn<sub>0.3</sub> Solid Solutions

Thermoelectric properties of Sb-doped Mg2Si0.59Sn0.41solid solutions

Fabrication Of Mg2si1-Xsnx From Mgh2 By Microwave-Assisted Solid State Reaction And Its Thermoelectric Performance

Thermoelectric Properties of Sb-doped Mg2 Si0.59 Sn0.41 Solid Solutions

Preparation and Transport Properties of Mg2 Si1-xSnxBiy Thermoelectric Materials by One-Step Synthesis Method

Reduced Lattice Thermal Conductivity In Bi-Doped Mg2si0.4sn0.6

Na/Bi-co-doping and Heterogeneous Interfaces Leading to Enhanced Thermoelectric Performance of P-Type Mg3Sb2-based Zintls

Thermoelectric Properties of Mg 2 (Si 0.3 Sn 0.7 ) 1− y Sb y Solid Solutions Doped with Co as CoSi Secondary Phase

High Figures Of Merit And Natural Nanostructures In Mg2si0.4sn0.6 Based Thermoelectric Materials