Abstract:Lead zirconate titanate (PbZrxTi1-xO3, or PZT) is a piezoelectric material widely used as sensors and actuators. For microactuators, PZT often appears in the form of thin films to maintain proper aspect ratios. One major challenge encountered is accurate measurement of piezoelectric coefficients of PZT thin films. In this paper, we present a simple, low-cost, and effective method to measure piezoelectric coefficient d33 of PZT thin films through use of basic principles in mechanics of vibration. A small impact hammer with a tiny tip acts perpendicularly to the PZT thin-film surface to generate an impulsive force. In the meantime, a load cell at the hammer tip measures the impulsive force and a charge amplifier measures the responding charge of the PZT thin film. Then the piezoelectric coefficient d33 is obtained from the measured force and charge based on piezoelectricity and a finite element modeling. We also conduct a thorough parametric study to understand the sensitivity of this method on various parameters, such as substrate material, boundary conditions, specimen size, specimen thickness, thickness ratio, and PZT thin-film material. Two rounds of experiments are conducted to demonstrate the feasibility and accuracy of this new method. The first experiment is to measure d33 of a PZT disk resonator whose d33 is known. Experimental results show that d33 measured via this method is as accurate as that from the manufacturer's specifications within its tolerance. The second experiment is to measure d33 of PZT thin films deposited on silicon substrates. With the measured d33, we predict the displacement of PZT thin-film membrane microactuators. In the meantime, the actuator displacement is measured via a laser Doppler vibrometer. The predicted and measured displacements agree very well validating the accuracy of this new method.

Simultaneous Piezoelectric and Ferroelectric Characterization of Thin Films for MEMS Actuators

Characterization of in‐plane piezoelectric strain of ferroelectric thin films by the magnetoelectric coupling effect

Converse mode piezoelectric coefficient for lead zirconate titanate thin film with interdigitated electrode

Integration of buried piezoresistive sensors and PZT thin film for dynamic and static position sensing of MEMS actuator

A wafer-level characterization method of thin film transverse piezoelectric coefficient evaluation

Measurements of Piezoelectric Coefficient d33 of Lead Zirconate Titanate Thin Films Using a Mini Force Hammer

PZT MEMS ACTUATOR WITH INTEGRATED BURIED PIEZORESISTORS FOR POSITION CONTROL

Fabrication and FEM Analysis of a Piezoelectric Thin-Film Microactuator

Enhanced piezoelectric performance of composite sol-gel thick films evaluated using piezoresponse force microscopy.

Preparation of (100)- and (111)-Textured Pb(Zr,Ti)O-3 Piezoelectric Films and Direct Measurement of Their Piezoelectric Constants

Accurate 3D Nanoscale Electromechanical Imaging with a Metrological Atomic Force Microscope

Resetting Piezoresponse Force Microscopy: Towards a real quantitative technique

Piezoresponse phase as variable in electromechanical characterization

Electrically induced strains and piezoelectric properties of thin layer ferroelectrics

Measurement of Transverse Piezoelectric Coefficients of Pb(Zr0.52Ti0.48)O3 Thin Films by a Mechano-electrical Multiphysics Coupling, Bulge Test Method

Sprouty-2 regulates oncogenic K-ras in lung development and tumorigenesis.

Trophoblastic tumour, unclassified with extensive metastasis associated with an uneventful pregnancy - A case report.

Fabrication and Characterization of Piezoelectric Cantilever for Micro Transducers

Nanoelectromechanics of Piezoresponse Force Microscopy

Ferroelectric thin films for piezoelectric micromotors

Piezoresponse Force Microscopy Imaging and Its Correlation with Cantilever Spring Constant and Frequency