Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Investigation of scattering mechanisms for scaled mosfets

Simulation Study of Device Physics Issues in III&#x2013;V MOSFETs at 10 Nm Node

Revealing the Scattering Mechanisms of Mobility Degradation in Ultrathin Body SOI Pmosfets

Performance Analysis of Ultra-thin-Body, Double-Gate pMOSFETs at 5 nm Technology Node

Influence of Channel Length, Thickness, and Crystal Orientation in Ultra-Scaled Double-Gate Pmosfets

Quantum Transport Study of Si Ultrathin-Body Double-Gate Pmosfets: ${I}$ – ${V}$ , ${C}$ – ${V}$ , Energy Delay, and Parasitic Effects

Investigations on the Physical Understanding of Mobility in MOSFETs - from Drift-Diffusion to Quasi-Ballistic

Quantitative Evaluation of Mobility Scattering Mechanisms in Ultra-Thin-Body Ge-OI pMOSFETs

Low-Field Mobility and Carrier Transport Mechanism Transition in Nanoscale Mosfets

Investigating scattering effects in nano-scale double gate MOSFETs by using direct solution of the Boltzmann transport equation and Poisson-Schrodinger equation method

Scattering Mechanisms in Inversion Layers of Ge MOSFETs: Impact of Surface States and Carrier Effective Masses

New Findings On The Scattering Mechanisms In Inversion Layers Of Ge (111), (110), And (100) Nmosfets Under High Electric Field - Differences With Si Nmosfets

Comparison of Different Scattering Mechanisms in the Ge (111), (110), and (100) Inversion Layers of Nmosfets with Si Nmosfets under High Normal Electric Fields

Numerical Electron Mobility Model of Nanoscale Symmetric, Asymmetric and Independent Double-Gate Mosfets

Performance degradation of superlattice MOSFETs due to scattering in the contacts

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Study on Electron Mobility in Nanoscale DG MOSFETs with Symmetric, Asymmetric and Independent Operation Modes

Device Simulation of Nano-Scale MOSFETs Based on Bandstructure Calculation

Comprehensive Understanding of the Mobility Scattering Mechanisms and Evaluation of the Universal Mobility in Ultra-Thin-Body Ge-OI p- and n-MOSFETs

Fringe-Induced Barrier Lowering (fibl) Included Sub-Threshold Swing Model for Double-Gate Mosfets