Abstract:Autothermal reforming (ATR) is an important technology for hydrogen production from natural gas, where soot formation deserves particular attention as it may cause catalyst poisoning. The typical configuration of ATR reactors is that of an inverse diffusion flame (IDF). In this study, soot formation near ATR condi-tions is investigated experimentally and numerically, focusing on the effects of pressure and CO2 dilution in IDFs with pressure reaching 5 bar. The fuel stream consists of methane diluted with CO2 or N2. The mole fraction of O2 in the oxidant stream is 70%. Polycyclic aromatic hydrocarbons (PAHs) and soot vol -ume fraction are measured by the planar laser-induced fluorescence (PLIF) and planar laser-induced in-candesce (PLII) methods. High-fidelity simulations with a detailed soot aerosol model are also performed, and an empirical reactive soot inception model is proposed. A comparison of the results shows that the soot behavior is well predicted by the empirical reactive inception model but not fully captured by the physical inception model based on irreversible dimerization, demonstrating the importance of radical in-volvement in the soot inception process. Both measurements and predictions show a linear relationship between peak soot volume fraction and pressure, which can be explained by the linear increase of PAH molar concentration with pressure. Simulation analysis indicates that the dimer adsorption and HACA mechanism have a similar quantitative contribution to the soot growth. The CO2 shows stronger suppres-sion effects in soot formation at the investigated pressures compared to N2. The contributions of chemical and thermal effects to soot suppression are numerically analyzed and the results indicate that the chem-ical effect of CO2 is mainly due to the removal of H radicals through the reaction CO2 + H & RARR; CO + OH, providing a soot suppression contribution of two times larger compared to the thermal one.& COPY; 2023 The Combustion Institute. Published by Elsevier Inc. All rights reserved.

Effect of Syngas Partial Pressure on Fischer-Tropsch Reaction Rate

Influence of Slurry Velocity and Concentration Distributions on Fischer-Tropsch Synthesis in Slurry Bubble Column Reactor

The Effects of CO2/CH4 Ratio on Soot Formation for Autothermal Reforming of Methane at Elevated Pressure

Effect of Pressure and CO2 Dilution on Soot Formation in Laminar Inverse Coflow Flame at Conditions Close to Autothermal Reforming

Effect of Co-Feeding Carbon Dioxide on Fischer–Tropsch Synthesis over an Iron–manganese Catalyst in a Spinning Basket Reactor

Experimental and simulation study of the temperature distribution in a bench‐scale fixed bed Fischer–Tropsch reactor

Modeling and operating conditions optimization of Fischer–Tropsch synthesis in a fixed-bed reactor

Effect of Pressure, H2/CO Ratio and Reduction Conditions on Co-Mn/CNT Bimetallic Catalyst Performance in Fischer-Tropsch Reaction

Influence of carbon deposits on Fe-carbide for the Fischer-Tropsch reaction

Fischer-Tropsch Synthesis on Fe-Co-Pt/γ-Al2O3 catalyst: A mass transfer, kinetic and mechanistic study

Effects of CO content on laminar burning velocity of typical syngas by heat flux method and kinetic modeling

Determination of Char-CO<sub>2</sub> Gasification Rate Through Reaction Product

Kinetics Studies of Cobalt Ft Catalyst Using High-Throughput Technology

Kinetic study of Fe & Co perovskite catalyst in Fischer–Tropsch synthesis

Kinetic estimation of Fischer–Tropsch synthesis using biogas-derived feedstocks over Ni/Al2O3 catalyst

Insight into the Rate-Determining Step and Active Sites in the Fischer–Tropsch Reaction over Cobalt Catalysts

Some new insights into the effect of CO2 partial pressure on the non-isothermal gasification

Effect of the CO coverage on the Fischer–Tropsch synthesis mechanism on cobalt catalysts

Reaction kinetics study of coal catalytic gasification in lab scale fixed bed reactor

Studies and Discriminations of the Kinetic Models for the Iron-Based Fischer−Tropsch Catalytic Reaction in a Recycle Slurry Reactor

Coal Char Gasification in the Mixture of H2O, CO2, H2, and CO under Pressured Conditions