Abstract:The slurry reactor with inert liquid can transfer heat in time and avoid the catalysts sintering, CO rich synthesis gas can be used in this reactor. In order to maintain both effective heat transfer and higher CO conversion, a slurry reactor in tandem with a fixed-bed reactor was used for DME synthesis. The synthesis gas was pre-mixed in a pressurized gas cylinder. The high pressure syngas was regulated and its flow rate was controlled by a mass flowmeter and fed to the reactor. The reaction pressure was kept by a back pressure regulator. The reactor effluent was analyzed on-line by two gas chromatographs. The experiments were carried out in the range of 220 ℃～260 ℃, 3.0 MPa～7.0 MPa and 500 mL·g -1·h -1～2 000 mL·g -1·h -1. The catalyst was a physical mixture of commercial methanol synthesis catalyst and methanol dehydration catalyst, the granularity was 0.15 mm～0.18 mm. The experimental results showed that the conversion of CO increased with increasing reaction temperature and pressure, the selectivity of DME was insensitive to temperature and pressure. 7.0 MPa and 260 ℃ were the optimal reaction conditions, at which 84.5% of CO conversion and 78.7% of DME selectivity were obtained while the the weight ratio of the catalysts loaded in the two reactors was 1∶1. Then DME synthesis reactions carried out in a fixed-bed reactor, a slurry reactor and the slurry-fixed-bed equipment respectively were compared and the adiabatic temperature rise of syngas was calculated. The results demonstrated that higher CO conversion was obtained in the slurry-fixed-bed equipment and the high temperature of hotspot was avoided simultaneously. Moreover, the catalyst was stable in the reactor during the 370 h reaction.

100 t/a-Scale demonstration of direct dimethyl ether synthesis from corncob-derived syngas

Pilot-Scale Tests of Direct Dimethyl Ether Synthesis from Biomass-Derived Syngas

Design and Operation of Integrated Pilot-Scale Dimethyl Ether Synthesis System Via Pyrolysis/gasification of Corncob

Scale study of direct synthesis of dimethyl ether from biomass synthesis gas.

DESIGN AND OPERATION ANALYSIS ON 100-TON SCALE DIRECT SYNTHESIS OF DME FROM BIOMASS SYNTHESIS GAS

Pilot Scale Study on Direct Synthesis of Dimethyl-Ether from Biomass Synthesis Gas

RESEARCH OF BIOGAS SYNTHESIZING DIMETHYL ETHER

Bio-syngas Production from Biomass Catalytic Gasification

Catalytic Pyrolysis of Corn Dried Distillers Grains with Solubles to Produce Hydrocarbons

Experimental study for dimethyl ether production from biomass gasification and simulation on dimethyl ether production

One-step synthesis of dimethyl ether from biomass-derived syngas on CuO-ZnO-Al2O3/HZSM-5 hybrid catalyst: Combination method, synergistic effect, water-gas shift reaction and catalytic performance

COMPARISON OF SINGLE STEP DIMETHYL ETHER CATALYSTIC SYNTHESIS FROM THREE TYPES OF BIOMASS-DERIVED SYNGAS

Direct synthesis of dimethyl ether from syngas containing N2 in a slurry reactor in tandem with a fixed-bed reactor

Experimental study on direct-fired characteristics about biomass derived crude syngas

Process Simulation of Single-Step Dimethyl Ether Production Via Biomass Gasification.

THE DIRECT SYNTHESIS OF DIMETHYL ETHER FROM SYNGAS OVER THE HYBRID CATALYST WITH ANTIMONY MODIFIED HZSM-5 ZEOLITE AS ACID COMPONENT

Single-Step Synthesis of Dimethyl Ether from Biomass-Derived Syngas over Cuo-Zno-Mox (M = Zr, Al, Cr, Ti)/Hzsm-5 Hybrid Catalyst: Effects of Mox

The Direct Synthesis of Dimethyl Ether from Syngas over Hybrid Catalysts with Sulfate-Modified Γ-Alumina As Methanol Dehydration Components

Synthetic fuels and chemicals production from biomass synthesis gas

Methanol Catalytic Synthesis from Cornstalk Gases

INTRINSIC KINETICS OF DIMETHYL ETHER SYNTHESIS FROM BIOMASS-SYNGAS IN A FIXED BED REACTOR