Abstract:Vented methane deflagrations in a 1 m3 vessel were investigated.Double flame acceleration phenomena were observed.CFD software FLACS was validated against experimental data.The mechanisms of the external overpressure peaks were revealed.The location of the external explosion was determined.This paper experimentally investigated the effect of low vent burst pressure on the overpressure buildup and flame evolution during the vented methane-air deflagrations in a 1 m3 rectangular vessel. CFD software FLACS was assessed in simulation of vented methane-air explosions against the experiment. Experimental results demonstrate that four overpressure peaks of Popen, Pout, Pext and Pacc from the vent failure, flame venting, external explosion and acoustically enhanced combustion, respectively, were observed except for the free venting case, in which only two overpressure peaks of Pout and Pext were monitored. The flame behaviors corresponding to different overpressure peaks were monitored especially at Pacc, where an abrupt increase in flame luminosity was observed on the bottom of the vessel due to the combustion of pockets of flammable mixture. Popen and Pacc increase with the vent burst pressure while Pout and Pext are nearly independent of the vent burst pressure. Double flame accelerations were observed owing to the vent rupture and flame venting. The phenomena of Helmholtz oscillation and the bulk motion of flame bubble always appeared after the vent rupture. The predicted overpressure agrees reasonably well with the experimental data. The discrepancy of the predicted and measured maximum peak overpressures reduces with increasing vent burst pressure. The predicted maximum peak overpressure and external flame length are slightly larger than those in experiment, which would facilitate the safe design in explosion venting and offer a better guidance in risk assessment. The simulation results also show that two overpressure peaks were recorded resulting from the pressure wave propagating above the vessel and the external explosion, respectively.

Design and Experimental Research on Venting Device for Cryostat System of EAST

Explosive Experiment of Mild Steel Pressure Vessel and Research on Formula of Explosive Stress

Theoretical and experimental study on sealing performance of a novel ultra-high pressure bursting disc

Study on Methods for the Reinforcement of Pressure Vessels with Large Openings

Design of Testing System of Electromagnetic Valve in Pneumatic ABS for Passenger Vehicles

Analysis on Underwater Blasting Shock Loading and Dynamic Response of Large Scale Radical Gate

Experiment and finite element analysis on pressure distention of laser welding dimple jacket

Experimental Investigation on the Deformation and Damage of Steel Ribbon Wound Vessel for Hydrogen Storage under External Impact and Blast Loading

A Deep-Sea Large-Volume High-Pressure Simulation System—design, Analysis and Experimental Verification

Design of High Pressure Reduction with Expander Pneumatic System' s Controller

Research on Hydrogen Environment Fatigue Test System and Correlative Fatigue Test of Hydrogen Storage Vessel

Theoretical and Experimental Research on Designed Bursting Pressure of Ultrahigh Pressure Rupture Disk

Study on Effect and Mechanism of Pressure Rise Rate on the Bursting Pressure of Conventional Domed Bursting Disc

Technical Research of Three-ultra Globe Valve for Aerospace Application

Instability Analysis and Development of High Pressure Hydrogen Storage Vessels

Dynamic Burst Pressure of Cylindrical Explosion Containment Vessels

Dynamic Characteristics Analysis on High Parameter Steam Spring-Loaded Safety Valve

Experimental and numerical study on the effect of low vent burst pressure on vented methane-air deflagrations

Design Verification and Performance Testing of Container Valves for Offshore 30mpa IG541 Fire Extinguishing System

Design and research on ultra-high pressure sealing structure based on tight plug ring

Investigation of Burst Pressure of Flat-Scored Metal Diaphragms in Hypersonic Impulse Facilities