Abstract:Coke-oven gas that contains mainly 57-62% H2, 25-28% CH4, and ∼6% CO is a a high quality hydrogen resource. However, coke-oven gas that contains more organic sulfur such as COS, thiophene S, and more tar can not be converted into syngas easily by Ni-catalyst process. Based on this limitation a new kind of catalyst, carbon catalyst for reforming CH4.in coke-oven gas to syngas was studied. The research of CH4-H2O (in coke-oven gas) reforming was taken in a Plug Flow Reactor (PFR). The research indicated that: 1) in the uncatalyed CH4-H2O reforming, the conversion rate of CH4 is lower. At the reaction temperature of 1100°C the conversion rate is about a half. However, in the carbon-catalyzed CH4-H2O reforming, the conversion rate of CH4 at 1100 is 97.4 %. The carbon catalyst can accelerate the reaction of CH 4-H2O reforming; 2) In the process of CH 4-H2O reforming, the reaction of water gas shift happened because of the existence of H2O and the component contents of the product gas have been changed. At lower temperatures, the water gas shift reaction has the trend of reduce the content of CO and increase the content of H2 in the product gas; 3) Because of the existence of water gas shift reaction, in the CH4-H2O reforming reaction, as the ratio of H 2O/CH4 was towards 1, the content of methane in coke-oven gas appeared towards highest; At 1200, with the staying time 0.5 seconds, the methane conversion rate in carbon catalyzed reaction is 85.5%. When the resident time lengthens to 1 second, the conversion rate of methane in coke-oven gas can reach above 95.0%. 4) At the temperature about 1000 carbon catalyst shows the catalytic activity on water gas shift reaction. When the reaction temperature reaches above 1050°C, the amount of CO2 will rapidly decrease to below 0.5%. This could be due to that at the temperature, the reaction between C and CO2 could rapidly increase, i.e. the CO2 from shifting reaction reacts with the C in catalyst, rapidly decreasing CO 2 contents. 5) The result of element analysis and specific surface area analysis of the carbon catalyst indicated that the contents of S and N in the carbon catalyst decreased sharply and the pore specific volume and the surface area increased after the reaction of CH4-H2O reforming.

Hydrogen Production from Coke Oven Gas by Methane Reforming: Thermodynamic Analysis and Experimental Study

The ReSER-COG Process for Hydrogen Production on a Ni–CaO/Al2O3 Complex Catalyst

Kinetic Study of Reactive Sorption-Enhanced Reforming of Coke Oven Gas for Hydrogen Production

Thermodynamic Simulation of Hydrogen Production from the Nano-Cao Reactive Sorption Enhanced Biomass Steam Reforming

Hydrogen production by CO2 reforming of CH4 in coke oven gas over Ni–Co/MgAl2O4 catalysts

Sorption-enhanced reforming of raw COG and its adaptability to hydrogen metallurgy: Thermodynamic analysis

Study of CH4-H2O in coke-oven gas reforming to produce syngas catalyzed by carbon catalyst

Thermodynamic Analysis of Aqueous Phase Reforming of Three Model Compounds in Bio-Oil for Hydrogen Production

Production of Syngas Via Partial Oxidation and CO2Reforming of Coke Oven Gas over a Ni Catalyst

Thermodynamic Analysis of A Biomass Anaerobic Gasification Process for Hydrogen Production with Sufficient Cao

A LOW-TEMPERATURE POM MICRO METHANOL REFORMER WITH HIGH FUEL CONVERSION RATE AND HYDROGEN PRODUCTION YIELD

Coproduction Of Hydrogen And Methanol From Methane By Chemical Looping Reforming

COG Based Syngas Production Process with Catalytic and Non-catalytic Partial Oxidation

Hydrogen Production by Catalytic Steam Reforming of Model Compounds of Bio-Oil

Thermodynamic Analysis of Steam Methane Reforming for Hydrogen Production

Reaction characteristics of hydrocarbon production by H 2O-CO 2 co-electrolysis in solid oxide electrolysis cells

Thermodynamic Analysis of Hydrocarbon Reforming

Waste coke oven gas used as a potential fuel for engines

Partial oxidation of methane in hollow‐fiber membrane reactors based on alkaline‐earth metal‐free CO2‐tolerant oxide

THERMODYNAMIC ANALYSIS OF HYDROGEN PRODUCTION BY NEW COAL UTILIZATION TECHNOLOGY WITH COMBINED GASIFICATION AND COMBUSTION

Progress on Catalyst of Partial Oxidation of Methane to Syngas