Abstract:Microscale boiling heat transfer experiments were performed using acetone as the working fluid in ten parallel silicon microchannels with hydraulic diameters of 155.4 mum. An infrared radiator image system is used for the chip temperature measurements, while an optical system combining a microscope and a high-speed camera is used for transient flow pattern identification. By covering the present data range it is found that all microchannels repeat the transient flow patterns in a timescale of milliseconds while the fluid pressures/temperatures are stable. A full cycle can be subdivided into three substages: liquid refilling stage, bubble nucleation, growth and coalescence stage, and transient annular flow stage. Correspondingly four flow patterns are identified. Paired or triplet bubbles are observed to be nucleated and grow up simultaneously in, or very close to, the channel corners at the same cross section. The nucleated bubbles experience several milliseconds of growth until coalescence takes place. Then a single liquid plug is separated into two parts, which are pushed out of the flow field view in less than 1 ms. In the transient annular flow stage, the liquid films that are drawn into the comers of the channel become less and less versus time. Once a partially or fully dried-out state is reached, all the microchannels are refilled with fresh liquid and a new cycle begins. The probabilities of each flow pattern occurring and the liquid refilling follow the statistical principle well. The measured chip temperatures are not uniform across the whole heating area, attributed to the uneven liquid refilling probabilities for different channels and the uneven possibilities that are immersed in the liquid for different heating regions. The chip temperatures display spatial variation behavior in the majority of the heating area, due to the liquid and vapor alternatively passing through the microchannels. To the authors' knowledge, some of the above experimental findings have not been previously reported.

Bubble Dynamics During Boiling in Polydimethylsiloxane (PDMS) Microchannels with Wire Heater

Boiling Regimes in Uncoated Polydimethylsiloxane Microchannels with A Fine Wire Heater

Nucleate Boiling Bubble Dynamics in a PDMS Microchannel with a Single Nucleation Site

Multi-Phase Pattern Evolution in Gas-Permeable Polydimethylsiloxane (pdms) Microchannels During Heating

Bubble circling phenomena in subcooled nucleate pool boiling on microwires

Microscale Boiling and Microbubble Dynamics under Pulse Heating

Capillary-Assisted Evaporation/Boiling in PDMS Microchannel Integrated with Wicking Microstructures

Thermocapillary Effect on Bubble Sweeping and Circling During Subcooled Nucleate Pool Boiling of Water over Microwire

Dynamic Bubble Behaviour During Microscale Subcooled Boiling

EXPERIMENTAL OBSERVATIONS OF BUBBLE DYNAMICS ON ULTRATHIN WIRES

Visualization and measurements of periodic boiling in silicon microchannels

Two Large-Amplitude/Long-Period Oscillating Boiling Modes in Silicon Microchannels

Jet Flows from Bubbles During Subcooled Pool Boiling on Micro Wires

Experimental Observation On Bubble Dynamics During Nucleate Boiling In Micro/Mini/Macro Tubes

Dynamic characteristics of transient boiling on a square platinum microheater under millisecond pulsed heating

AN EXPERIMENTAL STUDY OF BUBBLE FORMATION ON A MICROWIRE COATED WITH SUPERHYDROPHOBIC MICROPATTERNS

Visualization of Flow Patterns and Bubble Behavior During Flow Boiling in Open Microchannels

Two-Phase Flow Phenomena for Boiling in Two Parallel Microchannels

Dynamics of Bubble Motion and Bubble Top Jet Flows From Moving Vapor Bubbles on Microwires

Bubble Formation of Liquid Boiling in Microchannels

Microscale Boiling Heat Transfer in A Micro-Timescale at High Heat Fluxes