Abstract:Despite numerous studies focused on the hydrothermal (HT) synthesis of fly ash zeolites (FAZs), this method still has many limitations, the main of which is the low yield of zeolites. Hydrothermally synthesized zeolites are typically multiphase and exhibit low purity, which limits their applicability. Pure-phase zeolites have been primarily prepared from filtrates after alkaline mineralization of fly ashes, not directly in suspension. In addition, the published methodologies have not been tested in a wider set of samples, and thus their reproducibility is not confirmed. The aim of the study is to propose a reproducible methodology that overcomes the mentioned limitations. The influence of the Si/Al ratio (1.3:1–1:2), the type and concentration of the activator (2/4 M NaOH/KOH/LiOH), the reagent (30% LiCl), the duration (24–168 h), and the temperature (50–180 °C) of the synthesis phases were studied. The sequence of the synthesis phases was also optimized, depending on the type of heat transfer. The fly ashes were analyzed by wavelength-dispersive X-ray fluorescence (WD XRF), flame atomic absorption spectrometry (F-AAS), and X-ray diffraction (XRD). The energy intensity of the synthesis was reduced through the application of unique microwave digestion technology. Both microwave and combined (microwave and convection) syntheses were conducted. FAZs were identified and quantified by XRD analysis. This study presents a three-stage (TS) hydrothermal synthesis of pure-phase sodalite in suspension. Sodalite (>99 wt.%) was prepared from nine fly ashes under the following conditions: I. microwave phase: 120 °C, 150 min, solid-to-liquid ratio (S/L) 1:5, Si/Al ratio 1:1.5, and 4 M NaOH; II. convection phase: 120 °C, 24 h, S/L 1:40, and the addition of 30 mL of 30% LiCl; and III. crystallization: 70 °C for 24 h. The formation of rhombododecahedral sodalite crystals was confirmed by scanning electron microscope (SEM) images.

Hydrothermal Synthesis of Sodalite from Coal Fly Ash and Its Property Characterization

Dilithium Dialuminium Trisilicate Crystalline Phase Prepared from Coal Fly Ash

Effects of Sodium Carbonate and Sodium Chloride Additives on Alkaline Fusion of Coal Fly Ash

Synthesis and Characterization of Lithium Zeolites with Abw Type from Coal Fly Ash

Structure, morphology and mechanism research on synthesizing xonotlite fiber from acid-extracting residues of coal fly ash and carbide slag

Synthesis of NaHS zeolite using microwave assisted alkali activation of coal fly ash: preparation, mechanism, application

Microwave-Assisted Hydrothermal Synthesis of Pure-Phase Sodalite (>99 wt.%) in Suspension: Methodology Design and Verification

Transformation of Coal Gangue to Sodalite and Faujasite Using Alkali-hydrothermal Method

Synthesis of mesoporous sodalite from coal-fired slag for CO2 capture

A facile recrystallization strategy for fabrication of nanocrystalline microspheres of sulfatic sodalite with high thermal stability

Synthesis of zeolite Li-ABW from fly ash by fusion method

Kaliophilite from Fly Ash: Synthesis, Characterization and Stability

Synthesis and characterization of a single phase zeolite A using coal fly ash

Role of silicon in the growth of ZSM-5 synthesized with coal fly ash as raw materials

Synthesis of Sodalite Zeolite from Alkaline Fusion of Kaolin and Crystallization at Low Temperature and Ambient Pressure

Study on Preparation and Characterization of gamma-Al(2)O(3) from Coal Fly Ash

Influences of crystallization time, batch molar ratios Al2O3/SiO2 and Na2O/SiO2 on particulate properties of sodalite crystals prepared under room-temperature conditions

Effect of Temperature on the Synthesis of Sodalite by Crystal Transition Process

Manipulation of the Crystallization of Ssz-13 Transformed from Coal Fly Ash-Derived Analcime

Alkali-reinforced Hydrothermal Synthesis of Lathy Tobermorite Fibers Using Mixture of Coal Fly Ash and Lime

Optimization of crystal growth of hierarchical porosity ZSM-5 zeolite based on coal fly ash "waste utilization"Optimierung des Kristallwachstums hierarchischer Porositat ZSM-5-Zeolith auf Basis von Kohlenflugasche Mull-Verwendung"