Abstract:Formation of highly crystalline zinc oxide (ZnO) nanowires with an extremely high aspect ratio (length = 60 μm, diameter = 50 nm) is routinely achieved by introducing an intermediate step-oxidation method during the thermal oxidation process of thin zinc (Zn) films. High-purity Zn was deposited onto clean glass substrates at room temperature using a vacuum-assisted thermal evaporation technique. Afterwards, the as-deposited Zn layers were thermally oxidized under a closed air ambient condition at different temperatures and durations. Structural, morphological, chemical, optical and electrical properties of these oxide layers were investigated using various surface characterization techniques such as X-ray diffraction (XRD), scanning electron microscopy (SEM), Raman spectroscopy, and X-ray photoemission spectroscopy (XPS). It was noticed that the initial thermal oxidation of Zn films usually starts above 400 °C. Homogeneous and lateral growth of the ZnO layer is usually preferred for oxidation at a lower temperature below 500 °C. One-dimensional (1D) asymmetric growth of ZnO started to dominate thermal oxidation above 600 °C. Highly dense 1D ZnO nanowires were specifically observed after prolonged oxidation at 600 °C for 5 hours, followed by short-step oxidation at 700 °C for 30 minutes. However, direct oxidation of Zn films at 700 °C resulted in ZnO nanorod formation. The formation of ZnO nanowires using step-oxidation is explained in terms of surface free energy and compressive stress-driven Zn adatom kinetics through the grain boundaries of laterally grown ZnO seed layers. This simple thermal oxidation process using intermittent step-oxidation was found to be quite unique and very much useful to routinely grow an array of high-density ZnO nanowires. Moreover, these ZnO nanowires showed very high sensitivity and selectivity towards formaldehyde vapour sensing against few other VOCs.

Growth of ZnO nanowires with unusual growth directions

Molten Salt Route Toward the Growth of ZnO Nanowires in Unusual Growth Directions

Growth And Characterization Of Cu-Catalyzed Zno Nanowires

ZnO Nanowires Grown along the Non-Polar Direction

Growth and Electrical Properties of Zinc Oxide Nanowires.

Large-Scale Synthesis of Bicrystalline ZnO Nanowire Arrays by Thermal Oxidation of Zinc Film: Growth Mechanism and High-Performance Field Emission

Studies on the Synthesis and Growth Mechanism of Single Crystal ZnO Nanowires

Growth of Vertically Aligned ZnO Nanowire Arrays on ZnO Single Crystals

A Novel and Simple Growth Route Towards Ultra-Fine ZnO Nanowires

A Facile Shape-Selective Growth of Zno Nanotips and Graded Nanowires from Its Oriented Nanorods in A Saturated Zns Solution

Synthesis of Vertically Aligned Ultra-Long ZnO Nanowires on Heterogeneous Substrates with Catalyst at the Root.

Synthesis, Microstructure, and Growth Mechanism of Dendrite ZnO Nanowires

Growth of ultrafine ZnS nanowires

Growth of ZnO Nanowires by Free-Catalytic Thermal Evaporation of ZnS Powder

Wet chemical synthesis of ultralong and straight single-crystalline ZnO nanowires and their excellent UV emission properties

Growth mechanism and diameter control of well-aligned small-diameter ZnO nanowire arrays synthesized by a catalyst-free thermal evaporation method.

Controllable Preparation of 1-D and Dendritic ZnO Nanowires and Their Large Area Field-Emission Properties

Growth of single crystal zinc oxide beaded nanowires.

Surface energy and stress driven growth of extremely long and high-density ZnO nanowires using a thermal step-oxidation process

Controlled Growth of Zinc Nanowires

Morphology-controllable ZnO nanotubes and nanowires: Synthesis, growth mechanism and hydrophobic property