Abstract:The largest rare earth (RE) reserves minerals of China is the bastnaesite (RE[CO3]F) and monazite ((RE, Th)[PO4]) mixed type RE ore in Bayan Obo, and 90% of this concentrate is processed by the sulfuric acid roasting method. However, during purification of RE sulfate leach solution with solid MgO, the RE loss is noticeable and accompanied by a mass of acid and alkali consumption and discharge of radioactive solid waste, which also causes environmental pollution. In this paper, the behavior of RE, Fe, and P during purification were investigated focusing on the effect of pH, concentration ratio of iron and phosphorus, RE concentration, and step-wise purification (based on different pH) purification. The characterization of precipitated impurities by BET specific surface area, XRD, SEM and FTIR reveal the reaction sequence of RE loss and the formation of the precipitate. Two new factors, neglected previously, were found to be the main contributors to the production of large solid-waste:(1) sulfate which exists in the form of Fe(OH)x(SO4)(3-x)/2 accounts for 9 to 12% of the total weight of the precipitate; (2) higher solid content in the purification slurry at a relatively high pH range (pH = 2.5–4.5) significantly promotes the production of precipitate and higher loss of RE during purification. This paper proposes a two-step purification method (based on different middle pH point), step (i): a low pH purification stage in which most P, Fe(III) and H+ were removed with minimum loss of RE followed by filtration; step (ii), high pH purification stage in which the rest of Fe(III) was completely removed with less than 2% RE lost caused by low solid-to-liquid ratio consuming less MgO. Through two-step purification under the most suitable conditions, the RE recovery increased by 6% while MgO consumption and solid residue production decreased by 12% and 16%, respectively. It can greatly alleviate the environmental problems with just a minimal modification of the operation conditions and equipment in the proposed process.

Study on Purification Process of Yellow Phosphorus

A High-Efficiency and Energy-Saving Method for Purifying Industrial Silicon for Silicone Use

Present Situation and Prospect of Recovery and Utilization of Yellow Phosphorus Tail Gas

Phosphorus removal and recovery from wastewater by highly efficient struvite crystallization in an improved fluidized bed reactor

Purifying Yellow Phosphorus Tail Gas by Caustic Washing-Catalytic Oxidation

Experimental Research on a Process for the Recycling of Yellow Phosphorous Tail Gas to Produce Formic Acid

Research on Technology of Purifying Yellow Phosphorus Tail Gas to Produce Formic Acid and Dimethyl Carbonate

The impurities distribution and purification efficiency of high-purity aluminum preparation by zone melting in vacuum

Low-temperature enhancement in the extraction of phosphorus from metallurgical-grade silicon by simultaneously re-constructing phosphorus-rich phases of Ca3P2 and CaAl2Si2-P

A Full-Scale Study on Phosphorus Removal from Biological A/O Process Enhanced by Zeolite

Study on the occurrence state of main components of phosphogypsum dihydrate and its impurity distribution

Novel Synergistic Process of Impurities Extraction and Phophogypsum Crystallization Control in Wet-Process Phosphoric Acid

Preparation of High-Purity Tin by Zone Melting

Investigating the novel process for thorough removal of eutectic phosphate impurities from phosphogypsum

Investigating the recovery of ferrous phosphate in a fluidized bed crystallizer by response surface methodology

Preparation Status and Application Progress of Ultra-High Purity Zinc

Pilot test of removal of PH_3 and H_2S from yellow phosphorus tail gas

Separation behavior of trace impurities during deep purification of zone-fused germanium tailings via vacuum distillation

Comparative analysis of colloid-mechanical microenvironments on the efficient purification of phosphogypsum

Study of the Preparation of High Purity Silicon by a New Electro-thermal Metallurgy Method

Behavior of rare earth, iron, and phosphorus during purification of rare earth sulfate leach solution using magnesium oxide