Abstract:A numerical modeling study, based on 3D finite element method (FEM) simulation and 1D analytical solutions, has been carried out to evaluate the capabilities of two ac methods for measuring in-plane thermal conductivity of thin film deposited on the back of a suspended SiNx membrane setup. Two parallel metal strips are present on the top of the dielectric membrane. One strip (S1) serves as both heater and thermometer, while another one (S2) acts as thermometer only. For a modified phase shift (MPS) method, it is crucial to extract the in-plane thermal diffusivity from the phase shift of the temperature oscillation on S2. It was found that the frequency window for carrying out the data fitting became narrower as the in-plane thermal diffusivity of the composite membrane (<math>α∥,C</math>) increased, primarily due to the failure of the semi-infinite width assumption in the low frequency region. To ensure the validity of the method, the upper limit of <math>α∥,C</math> should not exceed ~1.8 × 10−5 m2 s−1 for the specific membrane dimension under consideration (1 × 1 mm2). On the other hand, inspired by a modified Ångström method proposed by Zhu recently, we suggest a new data reduction methodology which takes advantage of the phase shift on both S1 and S2 as well as the amplitude on S1. Based on the simulation results, it is expected that the non-ideality associated with the three "observables" may be at least partially canceled out. Therefore, the frequency window selection for carrying out the data fitting is not sensitive to the magnitude of <math>α∥,C</math> and the upper limit of measurable <math>αC,∥</math> can be further increased with respect to the MPS method. For typical specimen films whose in-plane thermal conductivity ranges from 0.84 W m−1 K−1 to 50 W m−1 K−1, the method proposed here yields a theoretical measurement uncertainty of less than 5%.

Design and simulation of comparative method for testing transverse thermal conductivity of SixNy thin film

A Method for Testing Thermal Conductivity of Multi-layer Films

Numerical modeling of in-plane thermal conductivity measurement methods based on a suspended membrane setup

Numerical Simulation of Direct Current Method of Measuring Thermal Conductivities of Thin Films

Cross-plane Thermal Conductivity and Thermal Diffusivity Measurement in Thin-Films by One-Dimensional Thermal Wave Method

Anisotropic thermal diffusivity measurement of thin films: From a few to hundreds of microns

An In-Situ Method for Comparing Thermal Conductivity of Insulation Film in Mems

Three-Sensor 2ω Method with Multi-directional Layout: A General Methodology for Measuring Thermal Conductivity of Solid Materials

Equivalence of the Equilibrium and the Nonequilibrium Molecular Dynamics Methods for Thermal Conductivity Calculations: from Bulk to Nanowire Silicon

A Numerical Study on the Theoretical Accuracy of Film Thermal Conductivity Using Transient Plane Source Method

Measurement of the Thermal Transport Properties of Dielectric Thin Films Using the Micro-Raman Method

Thermal Conductivity Measurements of Ultra-Thin Single Crystal Silicon Films Using Improved Structure

A Noncontact Method for Measuring Thermal Conductivity and Thermal Diffusivity of Anisotropic Materials

Raman Scattering Characterization of Transparent Thin Film for Thermal Conductivity Measurement

Lumped 3-D Equivalent Thermal Circuit Model for Transient Thermal Analysis of TSV Array

Comparison of four-probe thermal and thermoelectric transport measurements of thin films and nanostructures with microfabricated electro-thermal transducers

Flash DSC characterization of thermal contact resistance and cross-plane thermal conductivity of micrometer-thin films

Experimental Measurement of Thermal Conductivities in a Thin Heterogeneous Structure of Thermal Diodes

An improved steady-state method for measuring the thermal contact resistance and bulk thermal conductivity of thin-walled materials having a sub-millimeter thickness

Characterisation of High Thermal Conductivity Thin-Film Substrate Systems and Their Interface Thermal Resistance