Abstract:Ethanol dehydration is effectively catalyzed by strongly acidic zeolite catalysts which are known, however, to exhibit poor time on stream stability. Alumina and silica-alumina on the other hand are relatively stable but reach only low activity levels. Here, a series of aluminosilicate catalysts (Si:Al ratio = 16) was prepared by non-hydrolytic sol-gel (NHSG) and are shown to feature an intermediate level of activity, between the HZSM-5 zeolite and a commercial silica-alumina. Importantly, the best samples, were very stable with time on stream. Unlike HZSM-5, which also catalyzes ethylene oligomerization due to its strong acid sites and is therefore prone to coking, NHSG prepared catalysts did not produce any traces of ethylene oligomers and did not show any trace of coke formation. Characterization (ICP-OES, N 2 physisorption, TEM, XPS, IR coupled with pyridine adsorption, Raman spectroscopy, solid state NMR spectroscopy) reveal that the unconventional synthetic method presented here allowed to prepare mesoporous aluminosilicate materials with a remarkable degree of homogeneity. It is this thorough dispersion of Al in the amorphous silicate matrix which is responsible for the formation of acid sites which are intermediate (in terms of strength and nature) between those of commercial silica-alumina and HZSM-5 zeolite. The texture of the best NHSG catalyst – mainly mesoporous with a high specific surface area (800 m2 g −1 ) and pore volume (0.5 cm3 g −1 ) – was also unaffected after reaction. To overcome deactivation issues in ethanol dehydration, this study suggests to target amorphous aluminosilicate catalysts with open mesoporosity and with an intimate mixing of Al and Si.

Dehydration of Diluted Ethanol to Ethylene on Binder-Free HZSM-5 Zeolite Catalyst

Catalytic Performances of Binder-free ZSM-5 Catalysts for Dehydration of Crude Methanol to Dimethyl Ether

Fine‐tuning texture of highly acidic HZSM‐5 zeolite for efficient ethanol dehydration

Catalytic Performance and Coking Behavior of a Submicron HZSM‐5 Zeolite in Ethanol Dehydration

Regulating Surface Acid-Base Balance on NaZSM-5 by Fe Modification Towards Enhanced Methanol Dehydration to Dimethyl Ether

Ethanol Dehydration to Ethylene over HZSM-5 Catalyst Modified by Zn and Mn

Industrial crude bioethanol dehydration to ethylene: Doping ZSM-5 to enhance selectivity and stability

Bioethanol Dehydration To Bioethylene With Modified Zn/Mn/Zsm-5 Catalyst

Coking Behavior of Submicron ZSM-5 Zeolite Catalyst in Dehydration of Ethanol to Ethylene

Stability of Zeolite HZSM-5 in Liquid Phase Dehydration of Methanol to Dimethyl Ether

Ethylene production via ethanol dehydration over desilicated ZSM-5 catalyst

Highly Dispersed Crox Nanoparticles Modified Nazsm-5 for Lower Temperature Dehydration of Methanol to Dimethyl Ether

Low-Temperature Dehydration of Ethanol to Ethylene over Cu–Zeolite Catalysts Synthesized from Cu–Tetraethylenepentamine

Nanocrystalline H‐RTH Zeolite: An Efficient Catalyst for the Low‐Temperature Dehydration of Ethanol to Ethene

Interaction Between Binder and High Silica HZSM-5 Zeolite for Methanol to Olefins Reactions

The Pretreatment and Coking Behavior of Submicron ZSM-5 Zeolite Catalyst during Ethanol Dehydration

Mildly Acidic Aluminosilicate Catalysts for Stable Performance in Ethanol Dehydration

Deactivation and Regeneration of ZSM-5 Zeolite Catalysts for Ethanol Dehydration

Tuning the Acid Nature of the ZSM-5 Surface for Selective Production of Ethylene from Ethanol at Low Temperatures

Selective dehydration of bio-ethanol to ethylene catalyzed by lanthanum-phosphorous-modified HZSM-5: influence of the fusel

Effect of Modified Zeolite on One-Step Process of DME Synthesis