Abstract:In order to ensure that the supercritical CFB boiler has good wide-load operation characteristics and the ability of deep peak regulation， the transient heat transfer characteristics between the working fluid and the water wall under the change of transcritical pressure are experimentally studied. Experiment adopted Φ25 mm×3.5 mm vertical upward tube， the near-critical steady heat transfer experiment and the transcritical pressure step transient heat transfer experiment were carried out under the experimental conditions of 20～23 MPa of pressure and 400～800 kg/(m 2 ·s) of mass flow rate. The results showed that under the near-critical pressure， increasing the flow rate， reducing the heat flux on the inner wall， and reducing the pressure can reduce the dryness when the DNB heat transfer deterioration occurs， and increase the corresponding fluid enthalpy value， and delay the occurrence of the heat transfer deterioration. When the transcritical pressure step changes， the heat transfer deterioration may occur in the heating pipe， resulting in the wall temperature rising rapidly， but the temperature will fall back to the normal value with the increase of the flow rate. The heat transfer between the wall temperature rising point and the inner wall surface goes through the heat transfer deterioration stage， the subcooled boiling heat transfer enhancement stage and the single liquid phase heat transfer stage. The influence of each parameter on the heat transfer deterioration in the transcritical pressure step change experiment is the same as that in the near-critical steady state experiment. The decrease of flow rate and the increase of heat flux on the inner wall will advance the location of the heat transfer deterioration， and the wall temperature rise will be greater.

Research on the Water Wall Design and Hydrodynamic Characteristics of a 600 MW Supercritical Pressure CFB Boiler

Study on coal combustion characteristics in a 350MW supercritical tangentially boiler

Thermal–Hydraulic Calculation and Analysis on Water Wall System of a 700 MWe Ultra-Supercritical CFB Boiler

The hydrodynamic characteristics of embattlement shaped water wall of a 350 mw supercritical circulating fluidized bed boiler

Experimental investigation on dynamic characteristics of water wall during transcritical process of deep peak regulation for supercritical CFB boilers

Heat transfer characteristic of water wall and partition wall in a 600 MW CFB boiler

Steam and Water Wall Temperature of a 600mwe Supercritical Pressure Circulating Fluidized Bed Boiler

Hydrodynamics of the Water Wall in a 600 MW Supercritical Circulating Fluidized Bed Boiler With Water Cooled Panels Within the Furnace

Heat Flux Determination Based on the Waterwall and Gas–solid Flow in a Supercritical CFB Boiler

Heat Flux Distribution on Circulating Fluidized Bed Boiler Water Wall

Hydrodynamic Characteristics of Vertical Tubes With Low Mass Flux in Supercritical Pulverized Coal Boiler

Integrated Numerical Model for Ultra/Supercritical CFB Boilers

Investigation on Hydrodynamic Performance and Wall Temperature of Water-Cooled Wall in 1000 MW Boiler Under Low-Load Conditions

Steam Temperature Characteristics in Boiler Water Wall Tubes Based on Furnace CFD and Hydrodynamic Coupling Model

Structure and Performance of a 600MWe Supercritical CFB Boiler with Water Cooled Panels

Design and Research on a 600MWe Supercritical Circulating Fluidized Bed Boiler

Design and Development of a 660 MW High Efficiency Ultrasupercritical Double-furnace CFB Boiler

Heat transfer in a 600 Mwe supercritical circulating fluidized bed boiler with water cooled wall panels

Thermal-hydraulic Calculation and Analysis on Evaporator System of a 660 MWe Ultra-Supercritical CFB Boiler

Design and Operation of Experimental System for Studying Heat Transfer in a Smooth Tube at Near and Super Critical Pressure

Development of the Design of a 600 MW Low Mass Flow Speed Supercritical Pulverized Coal-fired Boiler with a Vertical Tube Coil