Abstract:This paper numerically investigates the physical mechanism of flow instability and heat transfer of natural convection in a cavity with thin fin(s). The left and the right walls of the cavity are differentially heated. The cavity is given an initial temperature, and the thin fin(s) is fixed on the hot wall in order to control the heat transfer. The finite volume method and the SIMPLE algorithm are used to simulate the flow. Distributions of the temperature, the pressure, the velocity and the total pressure are obtained. Then, the energy gradient theory is employed to study the physical mechanism of flow instability and the effect of the thin fin(s) on heat transfer. Based on the energy gradient theory, the energy gradient function K represents the characteristic of flow instability. It is observed from the simulation results that the positions where instabilities take place in the temperature contours accord well with those of higher K value, which demonstrates that the energy gradient theory reveals the physical mechanism of flow instability. Furthermore, the effects of the fin length, the fin position, the fin number, and Ra on heat transfer are investigated. It is found that the effect of the fin length on heat transfer is negligible when Ra is relatively high. When there is only one fin, the most efficient heat transfer rate is achieved as the fin is fixed at the middle height of the cavity. The fin blocks heat transfer with a relatively small Ra, but the fin enhances heat transfer with a relatively large Ra. The fin(s) enhances heat transfer gradually with the increase of Ra under the influence of the thin fin(s). Finally, a linear correlation of Kmax with Ra is obtained which reveals the physical mechanism of natural convection from different approaches.

Natural Convective Heat Transfer of Vacuum Circuit Breaker Radiator

Study of Heat Conduction Transfer Functions of Fins

Natural Convection Heat Transfer along Vertical Cylinder Heat Sinks with Longitudinal Fins

Heat Transfer in a High-Voltage Vacuum Circuit Breaker

Enhancing heat transfer in power transformer radiators via thermo-fluid dynamic analysis with periodic thermal boundary conditions

Study on LED Array Heat Radiator Improvement under Natural Convection

Simulation Researches on Influence Factors of Temperature Rise in High Voltage Vacuum Circuit Breaker

Numerical Study on Hydrodynamic and Heat Transfer Performances for Panel-Type Radiator of Transformer Using the Chimney Effect

Radiator based on circular radiating of liquid metal or alloy thereof for high-capacity direct-current circuit breaker

Numerical Investigation and Experimental Verification of the Fluid Cooling Process of Typical Stator–Rotor Machinery with a Plate-Type Heat Exchanger

Numerical study on natural convection heat transfer of fin-tube air-heating vaporizer

Experimental Investigation on Flow and Heat Transfer Performance of a Novel Heat Fin-Plate Radiator for Electronic Cooling

Thermal design of a novel heat sink cooled by natural convection with phase transition in the series loop

Three-dimensional numerical simulation on thermal performance in counter flow natural draft cooling tower

Direct Numerical Simulation of Turbulent Natural Convection in Riser of Passive Cooling System

Experimental research on vibration-enhanced heat transfer of fin-tube vehicle radiator

Numerical Simulation of Turbulent Natural Convection in an Enclosure with a Curved Surface Heated from Below

CFD Calculation of Natural Convection Heat Transmission in a Three-Dimensional Pool with Hemispherical Lower Head

Experimental Study of Composite Heat Pipe Radiator in Thermal Management of Electronic Components

Numerical Study of Natural Draft Wet Cooling Tower

Numerical simulation of flow instability and heat transfer of natural convection in a differentially heated cavity