Abstract:The development of concrete corrosion in new sewer pipes undergoes an initiation process before reaching an active corrosion stage. This initiation period is assumed to last several months to years but the key factors affecting the process, and its duration, are not well understood. This study is therefore focused on this initial stage of the corrosion process and the effect of key environmental factors. Such knowledge is important for the effective management of corrosion in new sewers, as every year of life extension of such systems has a very high financial benefit. This long-term (4.5 year) study has been conducted in purpose-built corrosion chambers that closely simulated the sewer environment, but with control of three key environmental factors being hydrogen sulfide (H2S) gas phase concentration, relative humidity and air temperature. Fresh concrete coupons, cut from an industry-standard sewer pipe, were exposed to the corrosive conditions in the chambers, both in the gas phase and partially submerged in wastewater. A total of 36 exposure conditions were investigated to determine the controlling factors by regular retrieval of concrete coupons for detailed analysis of surface pH, sulfur compounds (elemental sulfur and sulfate) and concrete mass loss. Corrosion initiation times were thus determined for different exposure conditions. It was found that the corrosion initiation time of both gas-phase and partially-submerged coupons was positively correlated with the gas phase H2S concentration, but only at levels of 10 ppm or below, indicating that sulfide oxidation rate rather than the H2S concentration was the limiting factor during the initiation stage. Relative humidity also played a role for the corrosion initiation of the gas-phase coupons. However, the partially-submerged coupons were not affected by humidity as these coupons were in direct contact with the sewage and hence did have sufficient moisture to enable the microbial processes to proceed. The corrosion initiation time was also shortened by higher gas temperature due to its positive impact on reaction kinetics. These findings provide real opportunities for pro-active sewer asset management with the aim to delay the on-set of the corrosion processes, and hence extend the service life of sewers, through improved prediction and optimization capacity.

Research on the Corrosion of Sewer System Pipelines from Domestic Wastewater

Effect of water supply pipe wall corrosion on chlorine decay

Corrosion Behaviors and Mechanical Properties of Q235 Steel Pipes Collapsing Due to Corrosion after 25-Year Service in Urban Industrial Atmospheric Environment

Corrosion of pipelines in urban water systems: Current research status and future trends based on bibliometric analysis

Corrosion of reinforcing steel in concrete sewers

Wastewater-Enhanced Microbial Corrosion of Concrete Sewers.

Detection and analysis of corrosion and failure of urban buried steel-made gas pipeline

Study On Distribution Of Steel Corrosion Products In Concrete Structures

Corrosion Failure Analysis on Water Pipeline

Measurement and Appraisal of the Corrosion of the Pipe Network of Urban Nature Gas

Understanding the early-stage spatially distributed behaviors of microbially induced concrete corrosion in the sewer system

SIMULATED RESEARCH ON CORROSION OF REINFORCEMENT IN CONCRETE UNDER CHLORIDE ENVIRONMENT

Identification of controlling factors for the initiation of corrosion of fresh concrete sewers.

Corrosion behavior and mechanism of ductile iron with different degrees of deterioration of cement mortar lining in reclaimed water pipelines

Effects of corrosive medium in domestic sewage on concrete strength

Research on the Corrosion Behavior of Q235 Pipeline Steel in an Atmospheric Environment through Experiment

A comprehensive literature mining and machine learning to decipher and predict effects of concrete materials on concrete corrosion of sewer pipe

Time-Variant System Reliability Analysis of Concrete Sewer Pipes under Corrosion Considering Multiple Failure Modes

Corrosion of Cast Iron in Reclaimed Municipal Wastewater

Field Experiment of Stress Corrosion Cracking Behavior of High Strength Pipeline Steels in Typical Soil Environments

Research on Corrosion Protection of Buried Steel Pipeline