Investigation into mercury transformation mechanisms in laboratory combustion systems

Jianli Ren,Jinsong Zhou,Zhongyang Luo,Kefa Cen

2003-01-01

Abstract:Mercury in the environment is a serious issue and mercury emission from coal-fired power plants is a major source of environmental pollution. This work was focused on the mechanism of mercury emission with different coal and reaction conditions. Firstly, the mercury content of the residual after coal combustion and pyrolysis was investigated with different temperature and heating time. The results indicate that mercury in coal during coal combustion discharge faster than during coal pyrolysis. Secondly, the experiments were carried out in a fixed-bed combustor and a bench-scale pulverized coal combustor. The experimental data showed that the speciation of mercury occurring under the above two systems were similar, but results from the latter are close to that from utility boilers. It shows that the gaseous mercury concentrations in the flue gas range from 10 and 15 mug/Nm(3), and that the content of Hg-g(2+) in the flue gas was about 40%. The content of mercury in the ash was below 20%, which suggested that most of the mercury went into the flue gas in gaseous state. These findings are similar to results reported from literature. In addition, the cooling rate of hot flue gas is considered to be an important factor tending to increase the conversion ratio of elemental mercury (Hg(g)degrees) to divalent mercury (Hg-g(2+)) with slower cooling rate.