Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

The Gate-Oxide Breakdown Effect Coupled By Channel Hot-Carrier-Effect In Soi Mosfet'S

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Hot-carrier-induced On-Resistance Degradation of Step Gate Oxide NLDMOS

Substrate and process dependence of gate oxide reliability of dual gate CMOS process

A Thorough Study of Quasi-Breakdown Phenomenon of Thin Gate Oxide in Dual-Gate CMOSFET's

Hot-Carrier-Induced Defects Distribution And Coupling Effect Of The Front And Back Interface Degradation In Soi Nmosfet'S Operating In A Bi-Mos Hybrid Mode

A comprehensive analysis of breakdown mechanisms in 4H-SiC MOSFET and JFET

A refined forward gated-diode method for separating front channel hot-carrier-stress induced front and back gate interface and oxide traps in SOI NMOSFETs

Degradation Effects of Gate Oxide and Sti Charge in Soi Ldmos

Hot Carrier Induced Degradation in Mesa-Isolated N-Channel SOI MOSFETs Operating in a Bi-MOS Mode

The analysis of the anomalous hot-carrier effect in partially depleted SOI pMOSFETs fabricated on modified wafer

Characterization of Oxide Charge During Hot-Carrier Degradation of Ultrathin Gate pMOSFETs--Investigated by Charge Pumping Technique

Analysis of single event effects by heavy ion irradiation of Ga2O3 metal–oxide–semiconductor field-effect transistors

Interface degradation in Si‐metal‐oxide‐semiconductor structures by homogeneous, microwave heating of channel carriers

Modeling of Charge-to-Breakdown with an Electron Trapping Model for Analysis of Thermal Gate Oxide Failure Mechanism in SiC Power MOSFETs

Oxide Breakdown Reliability of SiC MOSFET

Analysis of Gate Oxide Degradation Induced by Heavy Ion in SiC Power MOSFETs

Hot carrier degradation behavior in SOI dynamic-threshold-voltage nMOSFET’s (n-DTMOSFET) measured by gated-diode configuration

A Nanoscale Analysis Of The Leakage Current In Sio(2) Breakdown

Channel Hot-Carrier Effect of 4H-Sic MOSFET

Simulation of Suppression of Floating-Body Effect in Partially Depleted SOI MOSFET Using a Si1−xGex Dual Source Structure