Abstract:This paper aims to explore the effects of ultra‐low excess air coefficients on the combustion performance and NOx emission characteristics of coal‐fired boilers through industrial experiments conducted on a 600 MWe wall‐fired boiler. The results indicate that the burners demonstrate good ignition performance under different ultra‐low excess air coefficient conditions. As the excess air coefficient increases, the temperature in the main combustion zone rises, and the ignition distance of pulverized coal shortens. Under ultra‐low excess air coefficient conditions (such as 1.04), the unburned carbon content in fly ash reaches 5.50%, which is 3.23% higher than under the condition of 1.11, indicating poor pulverized coal burnout. When the excess air coefficient is close to the theoretical design value (such as 1.11), the carbon content in slag and the unburned carbon content in fly ash is relatively low (1.40% and 2.28%, respectively), indicating more complete combustion of pulverized coal. Additionally, the flue gas temperature at the air preheater outlet under this condition is relatively low; compared to the condition of an excess air coefficient of 1.07, the flue gas temperature is reduced by 6°C, thus reducing flue gas loss. Although the NOx concentration under the condition of an excess air coefficient of 1.11 is slightly higher, the quantity of cooling water is less. Flow field tracking of the powder verifies the flow path and characteristics of the primary air of the burners, and the results show that the primary air flow path of the burners is relatively concentrated, avoiding impingement on the water‐cooled walls and effectively preventing slagging issues on the water‐cooled walls. The research findings are of great significance for improving the operational performance and environmental protection level of coal‐fired boilers.

INVESTIGATION OF AERODYNAMICS AND NOx EMISSION PROPERTY IN A 600MW UTILITY BOILER WITH DEFLECTED SECOND AIR SYSTEM

Experimental and Numerical Investigation of NOx Emissiion Property in a 600MW Utility Boiler with Deflected Second Air System

Simulation of Slagging Prevention Property of the Furnace with Deviated Secondary Air System

STUDY ON ELIMINATING FIRE-CARRYING IN PRIMARY AIR JET ORIFICE BY ADMIXING EXHAUST GAS

Influence of Declivitous Secondary Air on Combustion Characteristics of a Down-Fired 300-Mwe Utility Boiler

Experimental research on the fire-carrying problems in primary air nozzle of 125 MW units

The integrated analysis of economy and safety on SOFA running mode of a 600MWe boiler

STUDY ON NUMERICAL SIMULATION OF DECREASING NOx EMISSION FROM COAL-FIRED BOILERS BASED ON BFA AND OFA

Investigations on combustion optimization and NOX reduction of a 600-MWe down-fired boiler: Influence of rearrangement of tertiary air and jet angle of secondary air and separated over-fire air

Investigation on slagging and high-temperature corrosion prevention and control of a 1000 MW ultra supercritical double tangentially fired boiler

E305 NUMERICAL SIMULATIONS ON THE EFFECT OF OVER-FIRE AIR TO THE COMBUSTION PERFORMANCE IN A 2950 T/H TANGENTIAL-FIRED BOILER(Boiler-1)

Effects of over Fire Air on the Combustion and Nox Emission Characteristics of A 600 Mw Opposed Swirling Fired Boiler

Numerical and experimental investigation on the reduction of NOx emission in a 600 MW utility furnace by using OFA

Optimizing the Combustion of Low-Quality Coal by the Wall Wind Auxiliary Combustion Method in a Tangentially Fired Utility Boiler

On-line monitoring of fouling on convective heating surface in utility boilers

Decoupling Investigation of Furnace Side and Evaporation System in a Pulverized-Coal Oxy-Fuel Combustion Boiler

Numerical Simulation of Secondary Air Penetration Depth in a 300 MW Single-furnace Circulating Fluidized Bed Boiler

Numerical experiment on complex characteristics of perimeter air deflectable deposited burner

Effect of bowl-shaped secondary air distribution on combustion efficiency and NOx mass concentration

Numerical Simulations On The Effect Of Over-Fire Air To The Combustion Performance In A 2950 T/H Tangential-Fired Boiler

Industrial experimental study on combustion characteristics and NOx emission characteristics of a 600 MWe wall‐fired boiler under ultra‐low excess air coefficient conditions