Abstract:Both experimentation and numerical simulations were conducted to study the effects of the overfire air (OFA) ratio on the coal combustion and NOx generation characteristics of a 600-MW downfired boiler after changing the air distribution around the fuel-rich flow. In these experiments, the arrangement of the secondary air ports close to the fuel-rich flow was adjusted to modify the air distribution around the fuel-rich flow. The air distributions in the total air duct at OFA damper openings of 30%, 40%, 50%, 70%, 80%, and 100% were calculated by numerical simulation to determine the theoretical air ratios, and these values were in good agreement with experimental results. The calculated air ratios were used as the inlet boundary conditions in subsequent simulations of the boiler thermal states. The calculated NOx emissions, carbon in fly ash, and gas temperatures in the lower furnace were also in good agreement with experimental data. Increasing the OFA damper opening from 30% to 80% generated both good flow and temperature symmetry while gradually reducing the airflow declination angles in the tertiary air regions, indicating reduced downward airflow depth. The flame kernel was also found to move upward. The OFA was readily drawn into the lower furnace at OFA damper openings below 50%, whereas larger openings gradually enhanced the OFA penetration. The corresponding experimental work demonstrated that increasing the opening from 30% to 80% increased the O2 concentration at the furnace exit from 3.02% to 3.51%, and NOx emissions were decreased from 1,337 to 735mg/m3 at 6% O2. Reducing the outer secondary air while simultaneously increasing the secondary air ratio between the fuel-rich flow nozzles increased the carbon in fly ash from 4.93% to 5.75%. However, values of 5.94%-15.1% where obtained upon increasing the OFA damper opening from 0% to 70% in conjunction with prior secondary air distribution around the fuel-rich flow. Under these conditions, the coal burnout was greatly enhanced and the lower furnace temperature and NOx emissions were slightly increased.

The integrated analysis of economy and safety on SOFA running mode of a 600MWe boiler

Numerical optimization of separated overfire air distribution for air staged combustion in a 1000 MW coal-fired boiler considering the corrosion hazard to water walls

Optimization of Separated Overfire Air System for A Utility Boiler from A 3-Mw Pilot-Scale Facility

Effect of Separated Over-Fire Air on Combustion Performance of a 3 MW Pilot-Scale Facility

Influence of Separated Overfire Air Ratio and Location on Combustion and NOx Emission Characteristics for a 600 MWe Down-Fired Utility Boiler with a Novel Combustion System

Numerical Study of Effect of Wall Separated Over-fire Air on Flue Gas Temperature Deviation in 660 MW Tangentially Coal-fired Boiler

Influence Of Wall-Sofa On The Gas Temperature Deviation Of A 660 Mw Tangentially Coal-Fired Boiler

Combined Effects of Yaw and Tilt Angles of Separated Overfire Air on the Combustion Characteristics in a 1,000 MW Coal-Fired Boiler: A Numerical Study

Experiment and Numerical Simulation Investigations of the Combustion and NOx Emissions Characteristics of an Over-Fire Air System in a 600 MWe Boiler

Investigations on combustion optimization and NOX reduction of a 600-MWe down-fired boiler: Influence of rearrangement of tertiary air and jet angle of secondary air and separated over-fire air

Effect of Separated Over-Fire Air Angle on Combustion and NOx Emissions in a Down-Fired Utility Boiler with a Novel Combustion System

Numerical Simulation of the NOx Emissions in a 1000 MW Tangentially Fired Pulverized-Coal Boiler: Influence of the Multi-group Arrangement of the Separated over Fire Air

Numerical Study on the Effect of Separated Over-Fire Air Ratio on Combustion Characteristics and NOx Emission in a 1000 MW Supercritical CO2 Boiler

Effect of the separated overfire air location on the combustion optimization and NOx reduction of a 600MWe FW down-fired utility boiler with a novel combustion system

Effects of over Fire Air on the Combustion and Nox Emission Characteristics of A 600 Mw Opposed Swirling Fired Boiler

Effects of OFA Ratio on Coal Combustion and NOx Generation of a 600-MW Downfired Boiler after Changing Air Distribution around Fuel-Rich Flow

Evaluation of overfire air behavior for a down-fired 350 MW e utility boiler with multiple injection and multiple staging

Experimental Research of Mitigation Strategy for High-Temperature Corrosion of Waterwall Fireside in a 630 MWe Tangentially Fired Utility Boiler Based on Combustion Adjustments

Comparison of NO<Subscript><Emphasis Type="Italic">x</Emphasis></Subscript> Emission Reductions with Exclusive SOFA and the Combination of SOFA and CCOFA on Tangentially-fired Boilers

Numerical Simulations of Flow, Combustion Characteristics, and NO X Emission for Down-Fired Boiler with Different Arch-Supplied Over-Fire Air Ratios

Numerical Simulation of the OFA Effect on Combustion in a 600 MWe Boiler with Centrally Fuel Rich Burners