Abstract:Both experimentation and numerical simulations were conducted to study the effects of the overfire air (OFA) ratio on the coal combustion and NOx generation characteristics of a 600-MW downfired boiler after changing the air distribution around the fuel-rich flow. In these experiments, the arrangement of the secondary air ports close to the fuel-rich flow was adjusted to modify the air distribution around the fuel-rich flow. The air distributions in the total air duct at OFA damper openings of 30%, 40%, 50%, 70%, 80%, and 100% were calculated by numerical simulation to determine the theoretical air ratios, and these values were in good agreement with experimental results. The calculated air ratios were used as the inlet boundary conditions in subsequent simulations of the boiler thermal states. The calculated NOx emissions, carbon in fly ash, and gas temperatures in the lower furnace were also in good agreement with experimental data. Increasing the OFA damper opening from 30% to 80% generated both good flow and temperature symmetry while gradually reducing the airflow declination angles in the tertiary air regions, indicating reduced downward airflow depth. The flame kernel was also found to move upward. The OFA was readily drawn into the lower furnace at OFA damper openings below 50%, whereas larger openings gradually enhanced the OFA penetration. The corresponding experimental work demonstrated that increasing the opening from 30% to 80% increased the O2 concentration at the furnace exit from 3.02% to 3.51%, and NOx emissions were decreased from 1,337 to 735mg/m3 at 6% O2. Reducing the outer secondary air while simultaneously increasing the secondary air ratio between the fuel-rich flow nozzles increased the carbon in fly ash from 4.93% to 5.75%. However, values of 5.94%-15.1% where obtained upon increasing the OFA damper opening from 0% to 70% in conjunction with prior secondary air distribution around the fuel-rich flow. Under these conditions, the coal burnout was greatly enhanced and the lower furnace temperature and NOx emissions were slightly increased.

Effect of the separated overfire air location on the combustion optimization and NOx reduction of a 600MWe FW down-fired utility boiler with a novel combustion system

Influence of Separated Overfire Air Ratio and Location on Combustion and NOx Emission Characteristics for a 600 MWe Down-Fired Utility Boiler with a Novel Combustion System

Effect of Separated Over-Fire Air Angle on Combustion and NOx Emissions in a Down-Fired Utility Boiler with a Novel Combustion System

Reducing NOx Emissions for a 600 MWe Down-Fired Pulverized-Coal Utility Boiler by Applying a Novel Combustion System

Optimization of Separated Overfire Air System for A Utility Boiler from A 3-Mw Pilot-Scale Facility

Investigations on combustion optimization and NOX reduction of a 600-MWe down-fired boiler: Influence of rearrangement of tertiary air and jet angle of secondary air and separated over-fire air

The integrated analysis of economy and safety on SOFA running mode of a 600MWe boiler

Combustion Optimization and NOx Reduction of a 600 MWe Down-Fired Boiler by Rearrangement of Swirl Burner and Introduction of Separated Over-Fire Air

Effect of Separated Over-Fire Air on Combustion Performance of a 3 MW Pilot-Scale Facility

Impact of the Overfire Air Location on Combustion Improvement and Nox Abatement of A Down-Fired 350 Mwe Utility Boiler with Multiple Injection and Multiple Staging

Numerical Simulations of Flow, Combustion Characteristics, and NO X Emission for Down-Fired Boiler with Different Arch-Supplied Over-Fire Air Ratios

Effect of Two-Level Over-Fire Air on the Combustion and NOxEmission Characteristics in a 600 MW Wall-Fired Boiler

Effects of OFA Ratio on Coal Combustion and NOx Generation of a 600-MW Downfired Boiler after Changing Air Distribution around Fuel-Rich Flow

Effect of Angle of Arch-Supplied Overfire Air on Flow, Combustion Characteristics and Nox Emissions of A Down-Fired Utility Boiler

Numerical optimization of separated overfire air distribution for air staged combustion in a 1000 MW coal-fired boiler considering the corrosion hazard to water walls

Experimental Study on a 200MW Boiler Retrofitted With Low NOx Combustion System

ICOPE-15-C078 Effects of Vent Air Angles on Combustion and NO Emission Characteristics for a Down-Fired 600MW Pulverized-Coal Utility Boiler Retrofitted with a Novel Combustion System

Combined Effects of Yaw and Tilt Angles of Separated Overfire Air on the Combustion Characteristics in a 1,000 MW Coal-Fired Boiler: A Numerical Study

Effect of Different Inner Secondary-Air Vane Angles on Combustion Characteristics of Primary Combustion Zone for A Down-Fired 300-Mwe Utility Boiler with Overfire Air

Experiment and Numerical Simulation Investigations of the Combustion and NOx Emissions Characteristics of an Over-Fire Air System in a 600 MWe Boiler

Numerical Study of Effect of Wall Separated Over-fire Air on Flue Gas Temperature Deviation in 660 MW Tangentially Coal-fired Boiler