Abstract:A new contactless velocity measurement sensor for bubble/slug flow in small scale pipes is developed with the contactless impedance detection (CID) technique. The new sensor consists of two same-designed CID modules (an upstream and a downstream) and an information processing module. In the upstream/downstream CID module, the capacitive reactance elimination principle is introduced to eliminate the adverse influence of coupling capacitances, and the analog phase sensitive demodulation (APSD) technique is adopted to obtain the fluid impedance signals (real part and imaginary part) of the gas-liquid two-phase flow. In the information processing module, the cross-correlation method is introduced to determine two initial bubble/slug velocities with real part and imaginary part of the fluid impedance, respectively. Then for each flow pattern, a velocity fusion model is established to fuse the two initial velocities. Based on the flow pattern identification result by a flow pattern classifier, the corresponding velocity fusion model is applied to determine the fused bubble/slug velocity. Three prototypes of the new sensor are developed and experiments are carried out. Experimental results show that the new sensor has good velocity measurement performance for bubble/slug flow in small scale pipes. For all the three prototypes, the maximum relative errors of velocity measurement are less than 3.0%. Results also indicate that the capacitive reactance elimination can successfully overcome the adverse influence of the coupling capacitances and taking full advantage of the total fluid impedance signals is an effective way to improve the velocity measurement accuracy.

Investigation on radioactive rays ionization gas flowmeter

Measuring Flow Velocity Distribution in Microchannels Using Molecular Tracers

A Model-Based Transit-Time Ultrasonic Gas Flowrate Measurement Method

New Contactless Velocity Measurement Sensor for Bubble/Slug Flow in Small Scale Pipes.

Design and Research of Signal Acquisition Circuit of Thermal Gas Flow-Meter

Study on new gas flow sensor based on hot-film probe

Real time infrared gas detection based on a modified EMD algorithm

Digital Image Processing Based Mass Flow Rate Measurement of Gas/solid Two-Phase Flow

A New Design for Ultrasonic Gas Flowmeter

Gas concentration detection based on LabVIEW and laser technique

A New Type Of Ultrasonic Gas Flowmeter With Multi-Tracks

Note: Ultrasonic Gas Flowmeter Based on Optimized Time-of-flight Algorithms.

A Study of Reflection Effect in Air-Coupled Lamb Wave Gas Flow Detection System

RESEARCH ON THE TRANSIENT RADIANT HEAT FLOW METER

A Gas Flow Measurement System Based on Lead Zirconate Titanate Piezoelectric Micromachined Ultrasonic Transducer

A Small Flow Point Signal Processing and Measurement Method for Ultrasonic Gas Meter

Gas Flow Rate Measurement in Low-Quality Multiphase Flows Using Venturi and Gamma Ray

Investigation of Flow Rate Measurement Method in Gas-Liquid Two-Phase Flow with High Gas Volume Fraction

Design of a High Precision Ultrasonic Gas Flowmeter

Experimental Study on Undisturbed Measurement of Gas Bubble Rising Velocity Using Infrared Emitting Diode and Photodiode

A novel ion detector aiming at the homogeneous of drift gas