Abstract:An accurate temperature analysis of electronic packaging requires an understanding of the thermal-transport parameters of the material. However, studies on the thermal conductivity of intermetallic compounds (IMCs) in micro-interconnect solder joints are scarce, particularly common IMCs forming in Cu-Sn systems, which seriously affect the precise prediction of the temperature field and thermal stress for electronic packaging structures. This work proposes a novel method to quantitatively measure the thermophysical parameters of Cu-Sn IMCs based on the dual-wavelength femtosecond laser timedomain thermoreflectance (TDTR) system. Cu-Sn diffusion couple samples were prepared using a reflow and aging process. Two layers of Cu6Sn5 and Cu3Sn IMCs formed at the interface with micron thickness, and the (001) crystal plane of Cu6Sn5 was the preferred orientation. The sensitivity of the experimental parameters to the measurement parameters affects the fitting accuracy. Therefore, before testing, the effects of the aluminum transducer thickness and pump laser modulation frequency on the phase signal sensitivity in the thermal conductivity measurements of Cu6Sn5 and Cu3Sn were analyzed to help select the specific experimental parameters. After testing, the thermal conductivities of Cu6Sn5 and Cu3Sn were 47.4 and 87.6 W/(m center dot K), respectively, which are slightly higher than the previous results because of the microstructure discrepancy caused by different material preparation techniques. Finally, the influence of the pump laser diameter, aluminum transducer thickness, and material specific heat on the measurement error of thermal conductivity for Cu6Sn5 and Cu3Sn was examined. The test errors of the Cu6Sn5 and Cu3Sn thermal conductivity were -6.8%similar to 4.6% and -7.1%similar to 4.4%, respectively. Overall, the TDTR technology can evaluate the thermal-transport characteristics of micron-scale intermetallic compounds in electronic packaging and guide the thermal design and reliability evaluations of electronic components.

Multiscale Investigation on Interfacial Properties of Cu/Al Structures in Electronic Packaging

Interfacial Heat Transfer Properties of the Typical Interconnection Structures in IC Packaging: a Multiscale Study

Hybrid Modeling and Analysis on the Interfacial Characteristics of Cu/Al Interface Structures in IC Packaging with Wire Bonding

Al-clad Cu Bond Wires for Power Electronics Packaging: Microstructure Evolution, Mechanical Performance, and Molecular Dynamics Simulation of Diffusion Behaviors

Numerical Investigation on Thermal Properties at Cu–Al Interface in Micro/nano Manufacturing

Investigation On Interfacial Thermal Resistances Of Al/Cu Structure By Using Hybrid Modeling With Multiscale Characteristics

Numerical Investigation on Atomic Migration Effect on Thermal Conductivity of Al/Cu Interface Structures in Electronic Interconnection Packaging

Characterization of interfacial delamination in multi-layered integrated circuit packaging

Interdiffusion Mechanism and Thermal Conductance at the Interfaces in Cu-to-Cu Bonds Achieved by Coating Nanolayers

The Effect of Phonon and Electron on Thermal Characteristics of Cu/Al Interface

Study on the Interfacial IMCs Growth of Nt-Cu/in Solder Joints

Numerical simulation of thermal properties at Cu/Al interfaces based on hybrid model

Md-Ise-Fe Multiscale Modeling and Numerical Simulation of Thermal Conductivity of Cu Film Interface Structure

Effect of atomic diffusion on interfacial heat transfer and tensile property of copper/aluminum composites

An atomic-continuum multiscale modeling approach for interfacial thermal behavior between materials

Computation of Thermal Properties of a Copper–copper Nano Interface Structure Using a MD–ISE–FE Method

Quasi In-Situ Study Of Morphological Evolution Of The Interfacial Imc In Single-Sided Interface Sn-0.3ag-0.7cu/Cu Joints During Multiple Reflow Process

Dislocation-based mechanical responses and deformation mechanisms of Al/Cu heterointerfaces: A computational study via molecular dynamics simulations

On the Evolution of Nano-Structures at the Al–Cu Interface and the Influence of Annealing Temperature on the Interfacial Strength

Atomistic Study of Atomic Structures and Dislocation Nucleation at Al/Al2Cu Interfaces

Investigations on the Thermal Conductivity of Micro-Scale Cu-Sn Intermetallic Compounds Using Femtosecond Laser Time-Domain Thermoreflectance System