High Reliability Tungsten-Doped Indium Zinc Oxide Thin Film Transistors for Display Applications
Jing-Zhong Deng,Tsung-Che Chiang,Zhen-Hao Li,Po-Tsun Liu,Yue Kuo
DOI: https://doi.org/10.1149/ma2023-02363346mtgabs
2023-12-22
ECS Meeting Abstracts
Abstract:Abstract Recently, flat panel display technologies are based on amorphous silicon (a-Si), polycrystalline silicon (poly-Si) or amorphous oxide semiconductor (AOS) thin film transistors (TFTs) technology. In order to reach higher performance for ultra-high resolution display applications, the material selection for the channel layer is vital. AOS TFTs drawn lots of attention because of its advantages such as low leakage current, high driving current and high uniformity [1,3]. In this work, we presented a novel amorphous oxide semiconductor (AOS) material of gallium-free a-InWZnO thin film transistors (IWZO TFTs) which is very promising to be applied for ultra-high resolution display technology. Experiment In this work, we demonstrated the structure of a-IWZO TFTs processes. Figure 1 shows the schematic of the TFT cross-section. After growing a 550 nm thermal oxide layer as buffer layer, a 25-nm-thick of molybdenum was deposited by DC-sputter as the bottom gate electrode. A 10-nm-HfO 2 was deposited by plasma-enhanced atomic layer deposition (PEALD) system as high-κ gate dielectric (GI). Then, post deposition annealing (PDA) was carried out to enhance the quality of the insulator layer. Next, an ultra-thin body a-IWZO was deposited by RF-sputter as channel layer. Finally, source and drain were defined by lift-off process and the gate contact via was etched by dry etching to finish the device fabrication. Result and Discussion Figure 1(b) shows the negative gate bias stress (NGBS) transfer curve (I D -V G ) of a-IWZO TFTs with passivation layer. The experimental results have shown that passivation layer could keep the back channel of IWZO channel from exposing to oxygen and hydrogen from the atmosphere. Without the passivation layer, the back channel would contact moisture leading the diffused hydrogen atoms to fill oxygen vacancy sites and de-trap free carriers, causing the V TH shifts negatively. The ultra-thin a-IWZO TFTs with passivation layer exhibited a low subthreshold swing (S.S.) of 89.7 mV/dec, high on/off current ratio (I ON /I OFF ) of 2.1×10 7 and small threshold voltage shift (ΔV th ) of -0.097 V during NGBS of -2MV/cm with 2000s. To sum up, the passivation layer could enhance the a-IWZO TFTs reliability. Reference [1] Kamiya, H. Hosono, NPG Asia Mater ., vol. 2, pp. 15, 2010. [2] Nomura, H. Ohta, A. Takagi, T. Kamiya, M. Hirano, and H. Hosono, nature, vol. 432, no. 7016, pp. 488-492, 2004. [3] Y. Kuo, C. M. Chang, I. H. Liu, and P. T. Liu, Scientific reports, vol. 9, no. 1, pp. 1-7, 2019. Figure 1