Abstract:The gallium–magnesium codoped zinc oxide (GMZO) thin films were deposited on glass substrates by radio frequency magnetron sputtering technique in an argon atmosphere. The influence of substrate temperature on the microstructure, morphology and optoelectronic properties of thin films was investigated by X-ray diffraction, scanning electron microscopy, X-ray photoelectron spectroscopy, four-point probe and spectrophotometry. It is found that all the deposited films have a hexagonal structure and a preferred orientation along the c-axis perpendicular to the substrate. As the substrate temperature increases, the dislocation density, lattice strain and electrical resistivity decrease initially and then increase, while the average crystallite size, average visible transmittance and figure of merit exhibit the reverse variation trend. The GMZO thin film deposited at the substrate temperature of 570 K possesses the best optoelectronic properties, with the largest average crystallite size of 52.05 nm, the lowest dislocation density of 3.69 × 1014 lines m− 2, the minimum lattice strain of 1.10 × 10− 3, the lowest electrical resistivity of 1.62 × 10− 3 Ω cm, the highest average visible transmittance of 88.63% and the maximum figure of merit of 5.11 × 103 Ω−1 cm− 1. The optical energy gaps of the films were evaluated by extrapolation method and observed to be in the range of 3.34–3.55 eV. Furthermore, the complex refractive index, the complex dielectric constant and the dissipation factor were determined by optical characterization methods, and the dispersion behaviour of refractive index was studied in terms of the single electronic oscillator model. The results show that the microstructure and optoelectronic properties of the GMZO thin films are dependent on substrate temperature.

Microstructure, optical and electrical properties of gallium-doped ZnO films prepared by sol-gel method

Microstructue and Optical Properties of Mg-doped ZnO Thin Films Prepared by Sol-gel Method

Effect of Na Concentrations on Microstructure and Optical Properties of Zno Films

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Optical and Electrical Properties of the LED Using ZnO:Ga Film As Current Diffusion Layer by Sol-gel Technique

Microstructure, surface morphology and optical properties of Na x Cu y Zn 1− x − y O thin films

Surface Morphology and Optical Properties of Na-doped ZnO Thin Films

Influence of Dopant Content on Morphology and Optical Constants of ZnO:Na Films by Sol-Gel Method

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Preparation and Characterization of Na-doped ZnO Thin Films by Sol–gel Method

Effect of Solution Concentrations on Crystal Structure, Surface Topographies and Photoluminescence Properties of ZnO Thin Films

Sol-Gel Preparation of Ag/ZnO Films and Their Electrical and Optical Properties

Investigation of the Microstructure, Optical and Electrical Properties of In-Ga-Zn Oxide Thin Film Using the Sol-Gel Method

Structural and Optical Properties of ZnO Thin Films Prepared by Sol–gel Method with Different Thickness

Microstructure, Optical and Photoluminescence Properties of Ga-doped ZnO Films Prepared by Pulsed Laser Deposition

Preparation and Thermochromic Properties of Sol-Gel-derived Zr-doped VO 2 Films

Microstructure and optoelectronic properties of gallium–magnesium codoped zinc oxide thin films by magnetron sputtering technique

Effect of the ZnO buffer layer thickness on AZO film properties

Investigation on the Structural and Optical Properties of ZnO Thin Films Prepared by Sol-Gel Method

Preparation and optical characteristics of ZnO films by chelating sol-gel method

Study on the Structural, Electrical, Optical, Adhesive Properties and Stability of Ga-Doped Zno Transparent Conductive Films Deposited on Polymer Substrates at Room Temperature