Abstract:Introduction: Robotic exoskeletons are emerging technologies that have demonstrated their effectiveness in assisting with Activities of Daily Living. However, kinematic disparities between human and robotic joints can result in misalignment between humans and exoskeletons, leading to discomfort and potential user injuries. Methods: In this paper, we present an ergonomic knee exoskeleton based on a dual four-bar linkage mechanism powered by hydraulic artificial muscles for stair ascent assistance. The device comprises two asymmetric four-bar linkage mechanisms on the medial and lateral sides to accommodate the internal rotation of the knee and address the kinematic discrepancies between these sides. A genetic algorithm was employed to optimize the parameters of the four-bar linkage mechanism to minimize misalignment between human and exoskeleton knee joints. The proposed device was evaluated through two experiments. The first experiment measured the reduction in undesired load due to misalignment, while the second experiment evaluated the device's effectiveness in assisting stair ascent in a healthy subject. Results: The experimental results indicate that the proposed device has a significantly reduced undesired load compared to the traditional revolute joint, decreasing from 14.15 N and 18.32 N to 1.88 N and 1.07 N on the medial and lateral sides, respectively. Moreover, a substantial reduction in muscle activities during stair ascent was observed, with a 55.94% reduction in surface electromyography signal. Discussion: The reduced undesired load of the proposed dual four-bar linkage mechanism highlights the importance of the adopted asymmetrical design for reduced misalignment and increased comfort. Moreover, the proposed device was effective at reducing the effort required during stair ascent.

Preliminary Evaluation of a Lower-Limb Exoskeleton - Stair Climbing

Preliminary Evaluation of Intelligent Intention Estimation Algorithms for an Actuated Lower-Limb Exoskeleton

An Upper-Limb Power-Assist Exoskeleton Using Proportional Myoelectric Control

Lower Extremity Exoskeleton for Stair Climbing Augmentation

Active Knee Joint Exoskeleton for Stair Ascent Augmentation

Ergonomic dual four-bar linkage knee exoskeleton for stair ascent assistance

Stair-ascent Strategies and Performance Evaluation for a Lower Limb Exoskeleton.

Design and Preliminary Evaluation of A Clutch-Spring Lower Limb Exoskeleton

Unpowered Knee Exoskeleton during Stair Descent

Design and First Operation of an Active Lower Limb Exoskeleton with Parallel Elastic Actuation

Lower Limb-Assisted Exoskeleton to Support Walking Up and Down Stairs

Development and Analysis of an Electrically Actuated Lower Extremity Assistive Exoskeleton

Design and Experimental Evaluation of a Lower-Limb Exoskeleton for Assisting Workers With Motorized Tuning of Squat Heights

Design and Evaluation of a Self-Aligning Knee Exoskeleton for Knee Extension Assistance During Walking

Evaluation of Lower Leg Muscle Activities During Human Walking Assisted by an Ankle Exoskeleton

Exoskeleton Design Utilizing Foot-Strike Energy for Enhancing the Climbing Ability of the Wearer

Analysis and Evaluation of a Quasi-Passive Lower Limb Exoskeleton for Gait Rehabilitation

Preliminary Evaluation Of Gait Assistance During Treadmill Walking With A Light-Weight Bionic Knee Exoskeleton

Preliminary Testing of a Passive Exoskeleton Prototype Based on McKibben Muscles

Learning and Planning of Stair Ascent for Lower-Limb Exoskeleton Systems.

Design an Underactuated Soft Exoskeleton to Sequentially Provide Knee Extension and Ankle Plantarflexion Assistance