Abstract:This work presents a study of the structural, morphological, and optical properties of titanium dioxide thin films prepared via plasma enhanced chemical vapour deposition at the floating potential (Vf) or substrate bias (Vb) of − 10 and − 50 V, after being submitted to annealing processes varying the temperature from 450 to 850 °C. By tuning the annealing temperature and substrate bias voltage respectively, which could be helpful for the explanation about the thermal effect and the influence of ion bombardment on TiO2 films obtained from low-temperature plasma deposition. The results have shown that the TiO2 thin films grown at Vf and − 10 V persist in the anatase phase even after annealing at 850 °C. The phase transformation from anatase to rutile occurred in the case of − 50 V, and the crystallization enhancement has been identified as the annealing temperature increased. From scanning electron microscopy measurements, the formation of gradient columnar morphology was also perceived in the cases of Vf and − 10 V, with increasing annealing temperature at 850 °C, these structures disappear transforming into homogeneous columns with larger size at Vf and granular structure at − 10 V. In the case of − 50 V, a well-organized columnar morphology has been found in the as-deposited film, and it also can be modified into granular structure with the post-annealing effect at 850 °C but without thickness reduction. Spectroscopic ellipsometry (SE) study was used to determine the effect of annealing temperature on the thickness and on the optical constant of TiO2 thin films. SE shows that the band gap of TiO2 thin films was found to decrease when the annealing temperature increases. Meanwhile, the annealing temperature of 450 °C leads to a decrease of refractive indices of the films grown at Vf and − 10 V, but has no effect on the film of − 50 V. Then further increase of annealing temperature at 850 °C, an improvement of refractive indices can be identified for all the films deposited with various bias voltages.

Phase formation tuning of oxygen-implanted layer on Ti6Al4V and Ti by annealing

Influence of Annealing Temperature on Microstructure and Phase Transformations of Oxide System Bi2O3/TiO2 Formed in Aqueous Solutions

Investigation of microstructure evolution in Pt-doped TiO2 thin films deposited by rf magnetron sputtering

Effect of Carbon and Oxygen on Phase Transformation of Titania Films During Annealing

Annealing and Biasing Effects on the Structural and Optical Properties of PECVD-grown TiO2 Films from TTIP/O2 Plasma

Local structure modification and phase transformation of TiO2 nanoparticles initiated by oxygen defects, grain size, and annealing temperature

A study on the Raman response of TiO2 upon ion-implantation and annealing in O2 atmosphere

Implantation of Carbon to Stabilize TiSi2 During Thermal Annealing

Anisotropic Phase Transformation Mechanism on Coarse-Grained and Fine-Grained Pure Titanium at Low-Temperature Plasma Nitriding

Phase Formation in Annealed Sputtered (Fe,ti)-N Films

Comprehensive microstructural and optical characterization of the thermal stability of aluminum-titanium oxynitride thin films after high temperature annealing in air

Synthesis, Phase Transition and Optical Properties of Nanocrystalline Titanium Dioxide Films Deposited by Plasma Assisted Reactive Pulsed Laser Deposition

Nucleation dynamics of nanostructural TiO2 films with controllable phases on (001) LaAlO3.

Influence of oxygen ingress on microstructure and phase formation during two-step oxidation surface hardening of TiZrNbHfTa high entropy alloy

The α 2 to orthorhombic O-phase transformation-facilitated high elastically mediated strain transfer ability in high Nb-TiAl alloys

Structural evolution of amorphous and nanocrystalline TiAl films under helium implantation

Structural and Conductive Changes of Alumina Ceramics and Silicon Crystal Implanted with High-Flux Ti Ion

Microstructures of Ti6Al4V matrices induce structural evolution of bioactive surface oxide layers via cold compression and induction heating

Thermal Stability of Pt-Ti Bilayer Films Annealing in Vacuum and Ambient Atmosphere

Preparation and Phase Structures of Zn–Ti–O Ternary Compounds by Atomic Layer Deposition

Fabrication and properties of TiO2 nanofilms on different substrates by a novel and universal method of Ti-ion implantation and subsequent annealing