Abstract:This work presents a study of the structural, morphological, and optical properties of titanium dioxide thin films prepared via plasma enhanced chemical vapour deposition at the floating potential (Vf) or substrate bias (Vb) of − 10 and − 50 V, after being submitted to annealing processes varying the temperature from 450 to 850 °C. By tuning the annealing temperature and substrate bias voltage respectively, which could be helpful for the explanation about the thermal effect and the influence of ion bombardment on TiO2 films obtained from low-temperature plasma deposition. The results have shown that the TiO2 thin films grown at Vf and − 10 V persist in the anatase phase even after annealing at 850 °C. The phase transformation from anatase to rutile occurred in the case of − 50 V, and the crystallization enhancement has been identified as the annealing temperature increased. From scanning electron microscopy measurements, the formation of gradient columnar morphology was also perceived in the cases of Vf and − 10 V, with increasing annealing temperature at 850 °C, these structures disappear transforming into homogeneous columns with larger size at Vf and granular structure at − 10 V. In the case of − 50 V, a well-organized columnar morphology has been found in the as-deposited film, and it also can be modified into granular structure with the post-annealing effect at 850 °C but without thickness reduction. Spectroscopic ellipsometry (SE) study was used to determine the effect of annealing temperature on the thickness and on the optical constant of TiO2 thin films. SE shows that the band gap of TiO2 thin films was found to decrease when the annealing temperature increases. Meanwhile, the annealing temperature of 450 °C leads to a decrease of refractive indices of the films grown at Vf and − 10 V, but has no effect on the film of − 50 V. Then further increase of annealing temperature at 850 °C, an improvement of refractive indices can be identified for all the films deposited with various bias voltages.

Effect of Carbon and Oxygen on Phase Transformation of Titania Films During Annealing

Influence of Annealing Temperature on Microstructure and Phase Transformations of Oxide System Bi2O3/TiO2 Formed in Aqueous Solutions

Investigation of microstructure evolution in Pt-doped TiO2 thin films deposited by rf magnetron sputtering

Annealing Temperature Dependent Microstructure and Optical Properties of HfxTi1-xO2 Thin Films

Influence of Carbon on Phase Transformation of Oxides in Carbon/Oxide Composites

Influence of Annealing Temperature on the Properties of Titanium Oxide Thin Film

The effect of an annealing process on atomic layer deposited TiO2thin films

Crystallization Behaviors of TiO2 Films Derived from Thermal Oxidation of Evaporated and Sputtered Titanium Films

Role of carbon in titania as visible-light photocatalyst prepared by flat-flame chemical vapor condensation method

Synthesis, Phase Transition and Optical Properties of Nanocrystalline Titanium Dioxide Films Deposited by Plasma Assisted Reactive Pulsed Laser Deposition

The Role of Oxygen Vacancy in Anatase to Rutile Transformation of TiO 2

Compositional and Structural Evolution of the Titanium Dioxide Formation by Thermal Oxidation

The Role of Oxygen Vacancy in Anatase to Rutile Transformation of TiO2

Local structure modification and phase transformation of TiO2 nanoparticles initiated by oxygen defects, grain size, and annealing temperature

Influence of Ti Content on the Partial Oxidation of TixFeCoNi Thin Films in Vacuum Annealing.

Effect of annealing temperature on phase transition and optical property of titanate nanotubes prepared by ion exchange approach

Annealing and Biasing Effects on the Structural and Optical Properties of PECVD-grown TiO2 Films from TTIP/O2 Plasma

Exploring annealing-triggered phase transformation, photoluminescence quenching, and synergistic effects of Co-doped TiO 2 nanoparticles

Effect of annealing temperature of titanium dioxide thin films on structural and electrical properties

Black TiO2 and Oxygen Vacancies: Unraveling the Role in the Thermal Anatase-to-Rutile Transformation

Effect of annealing treatment on the microstructure and current carrying tribological properties of in-situ formed TiO2−x coating prepared by plasma spraying