Abstract:In this paper, 2 atom % Al-doped ZnO (AZO) was prepared by the co-precipitation method together with sparking plasma sintering (SPS) treatment. The as-synthesized AZO powders show the morphology of hollow hexagonal towers, which result in a high porosity of 50.6% in the bulk sample consolidated by SPS sintering at 400 °C, and the porosity decreases gradually with increasing sintering temperature up to 1000 °C. Positron annihilation measurements reveal that even after sintering at 1000 °C, there are still a considerable number of small pores. A high electrical conductivity of 3 × 105 S m–1 is achieved at room temperature for the AZO sample sintered at 1000 °C, while the absolute values of Seebeck coefficient keep at relatively high values between 59 and 144 μV K–1 in the measurement temperature range of 27–500 °C, leading to a high power factor of 3.4 × 10–3 W m–1 K–2. On the other hand, the pores in AZO act as strong phonon scattering centers, and an extremely low thermal conductivity of 1.5 W m–1 K–1 measured at room temperature is obtained for AZO sintered at 400 °C. Due to the residual pores in the 1000 °C-sintered sample, the thermal conductivity is still relatively low. As a result, a maximum ZT of 0.275 measured at 500 °C is obtained in this sample, which is the highest ZT reported for ZnO around this temperature.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acsami.0c16506?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acsami.0c16506</a>.Thermal gravity analysis for the Al-doped ZnO (Figure S1), TEM images of Al-doped ZnO sintered at different temperatures (Figure S2), and structural characterization and thermoelectric properties of undoped ZnO prepared by co-precipitation combined with SPS treatment (Figures S3–S5) (<a class="ext-link" href="/doi/suppl/10.1021/acsami.0c16506/suppl_file/am0c16506_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Microwave dielectric properties of Al-doped ZnO powders synthesized by coprecipitation method

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Infrared Emission Characteristic and Microwave Loss Property of Aluminum Doped Zinc Oxide Nanoparticles

High Dielectric Constant in Al-doped ZnO Ceramics Using High-Pressure Treated Powders

Microstructure and Electrical Properties of Al-doped ZnO Thin Films

Effects of Al doping on the optical and electrical properties of pre-synthesized ZnO powders by solid state method

Preparation And Properties For Aluminum-Doped Zinc Oxide Powders With The Coprecipitation Method

Study on Aluminum Concentration on Optical and Electrical Properties of AZO Thin Films Fabricated by Ultrasonic Spray Pyrolysis

Significant Enhancement in the Thermoelectric Performance of Aluminum-Doped ZnO Tuned by Pore Structure

Tailoring of Optical and Electrical Properties of Transparent and Conductive Al-doped ZnO Films by Adjustment of Al Concentration

Influence of Al Doping on the Properties of Zno Thin Films Grown by Atomic Layer Deposition

Modification of MgAl<sub>2</sub>O<sub>4</sub> Microwave Dielectric Ceramics by Zn Substitution

Phase Composition, Crystal Structures and Enhanced Microwave Dielectric Properties of Mg2+/Zr4+ Co-Doped Al2Mo3O12 Ceramics

Preparation and Properties of Aluminum-Doped Zinc Oxide Ultrafine Powders

Effects of Al Doping on the Properties of ZnO Thin Films Deposited by Atomic Layer Deposition

Microstructure and optical properties of ZnAlO films prepared by Magnetron sputtering

Thermoelectric Properties and Electronic Structure of Al-Doped Zno

Enhanced microwave absorption of flaky FeSiAl/ZnO composites fabricated via precipitation

Ultra‐high Quality Factor of (zn2/3nb1/3)3+ Co‐substitution MgAl2O4 Microwave Dielectric Ceramics

Optical Properties of Al-doped ZnO Thin Films by Ellipsometry

Studies on Morphology, Electrical and Optical Characteristics of Al-doped ZnO Thin Films Grown by Atomic Layer Deposition