Abstract:The removal of low concentration ammonia-nitrogen in industrial wastewater is necessary before discharged into the environment. In this study, vacuum plate membrane distillation (VPMD) technology was utilized and operating parameters such as pH, feed temperature, vacuum degree, feed flow and time were investigated. Based on the experimental data, the heat and mass transfer mechanism and mathematic model were studied. The experimental results show that low solution pH was significantly beneficial to ammonia-nitrogen removal but permeate flux was nearly changeless. At pH = 4, a removal rate up to 93.33% was achieved. Ammonia-nitrogen mainly exists with NH4+ ions in acidic solution, so only water molecules pass through the membrane to acquire the water product in the permeate side. Increasing the temperature of the solution was disadvantageous to the ammonia-nitrogen removal due to membrane pores expanding and the mass transfer coefficient of NH3 molecules increasing; therefore a low temperature was chosen if possible. Because vapor pressure of the feed solution increases exponentially with temperature and results in membrane surface pressure difference increases, therefore increasing the temperature enhances the permeate flux. Raising the vacuum degree enhanced ammonia removal rate and permeate flux obviously, a vacuum degree of 0.09 MPa was chosen for the experiment. The effect of feed flow rate on ammonia-nitrogen removal instead of permeate flux is weak, the reason is that the boundary layer wears thin when the feed flow rate is increased, which is conducive to permeate flux increasing. In a two-parameter model of Knudsen diffusion, Poiseuille flow was chosen to demonstrate the heat and mass transfers in the process of VPMD in the study. Based on the experimental values of permeate flux, two parameters CK and CP in the model were calculated using a nonlinear fitting method software, which indicated that the Knudsen diffusion model more than the Poiseuille flow model was suitable. The maximum values of the relative average deviation (RAD) and root mean square difference (RMSD) of experimental and calculated values with model equations of the permeate flux at the different temperature, vacuum degree and feed flow rate were no more than 8.7% and 3.20 kg · (m2 · h)-1, respectively.

Experimental Study of Ammonia Removal from Water by Modified Direct Contact Membrane Distillation

De-ammonification using direct contact membrane distillation – An experimental and simulation study

Ammonia recovery from simulated anaerobic digestate using a two‐stage direct contact membrane distillation process

Ammonia Removal from Municipal Wastewater Via Membrane Capacitive Deionization (MCDI) in Pilot-Scale

Direct Contact Membrane Distillation Mechanism for High Concentration NaCl Solutions

Contactless membrane distillation for effective ammonia recovery from waste sludge: A new configuration and mass transfer mechanism

Research On The Application Of Membrane Absorption For The High Concentration Ammonia Wastewater Treatment

Performance evaluation and optimization of hollow fiber membrane contactors for carbon dioxide absorption: A comparative study of ammonia, ethanolamine, and diethanolamine solvents

A Novel Method to Recover Ammonia Loss in Ammonia‐based CO 2 Capture System: Ammonia Regeneration by Vacuum Membrane Distillation

Experimental study of arsenic removal by direct contact membrane distillation.

Nafion-PTFE hollow fiber composite membranes for ammonia removal and recovery using an aqueous-organic membrane contactor

Fluoride removal from aqueous solution by direct contact membrane distillation: theoretical and experimental studies

A Feasibility Study of Ammonia Recovery from Coking Wastewater by Coupled Operation of a Membrane Contactor and Membrane Distillation

Preparation and Characterization of PVDF/nonwoven Fabric Flat-Sheet Composite Membranes for Desalination Through Direct Contact Membrane Distillation

Water Reduction and Nutrient Reconcentration of Hydrolyzed Urine Via Direct-Contact Membrane Distillation: Ammonia Loss and Its Control

Study on efficient removal technology of ammonia nitrogen by membrane separation

Improvement of Membrane Distillation Using PVDF Membrane Incorporated with TiO2 Modified by Silane and Optimization of Fabricating Conditions

Removal of ammonia nitrogen from water by mesoporous carbon electrode–based membrane capacitance deionization

Surface functionalization of polytetrafluoroethylene membrane by polydopamine and quaternary ammonium compound for fouling mitigation in membrane distillation of secondary effluent

Study on treatment of wastewater with low concentration of ammonia-nitrogen by vacuum plate membrane distillation technology

The design of multi-stage open-loop hollow fiber membrane contactor and its application in ammonia capture from hydrolyzed human urine