Abstract:The nucleate boiling heat transfer in a slush nitrogen pool has been studied across a heat -flux range from 5 to 400 kW/m 2 and a system pressure range from 12.5 kPa (triple point pressure) to 101 kPa (atmospheric pressure). The effect of solid nitrogen on the heat transfer process was found to vary with the heat flux and the pressure. Experimental results reveal that the nucleate boiling heat transfer coefficient (HTC) of slush nitrogen is higher than that of subcooled liquid nitrogen at the low heat flux, which can be attributed to the fact that the solid nitrogen particles (with their latent heat of melting) absorb heat in the thermal boundary layer and form a sharper temperature gradient near the boiling surface. However, at the high heat flux, the HTC of slush nitrogen is lower than that of subcooled liquid nitrogen, which can be attributed to the invasion and inhibition occurring between the solid nitrogen particles and the bubbles during boiling, leading to the accumulation of vapor phase with low thermal conductivity on the boiling surface, thereby the heat transfer will be suppressed. As a result, a dual effect for the nucleate boiling heat transfer in slush nitrogen can be observed. Furthermore, the critical heat flux (CHF) of slush nitrogen is obtained and compared with the CHF of subcooled liquid nitrogen. According to the CHF model, the bubble period is the dominant parameter in determining the CHF. A calibrated CHF correlation for slush nitrogen is developed based on the hypothesis that the bubble period is prolonged as the effective viscosity of slush nitrogen increases with the solid volume fraction. The CHF values of slush nitrogen with the solid volume fraction of 10%, 20% and 30% are 0.96, 0.91 and 0.84 times those of subcooled liquid nitrogen, respectively, at the pressures higher than 50 kPa. Consequently, the solid volume fraction of slush nitrogen and the degree of subcooling of subcooled liquid nitrogen are found to have opposite effects on CHF.

Experimental study of production and flow characteristics of slush nitrogen

Numerical simulation on pressure drop of slush nitrogen flow inside a horizontal pipe

Pressure Drop and Flow Pattern of Slush Nitrogen in a Horizontal Pipe

Forced convective heat transfer of slush nitrogen in a horizontal pipe

Flow Field and Friction Factor of Slush Nitrogen in a Horizontal Circular Pipe

Numerical Investigation of Slush Nitrogen Flow in a Horizontal Pipe

Research status on slush hydrogen and slush nitrogen

Numerical Modeling for the Flow and Heat Transfer of Slush Nitrogen in a Horizontal Pipe Based on Population Balance Equations

The Effect of Solid Nitrogen on Nucleate Boiling Heat Transfer in a Slush Nitrogen Pool

Experimental study of double direct contact ice slurry generator

Research on the ice slurry generator using the direct contact heat transfer of gas and water solution

Research on the Structural Performance of Liquid Nitrogen Ice Plugs on Nuclear Power Pipes

Analysis of Ice Slurry Production by Direct Contact Heat Transfer of Air and Water Solution

Influence of Process Parameters on Production of Slush Hydrogen by Freeze-Thaw Method

Two-phase flow characteristics of liquid nitrogen in vertically upward 0.5 and 1.0mm micro-tubes: Visualization studies

Experimental study on the freezing process of water droplets for ice air jet technology

Comparative Experiments on the Flow Morphology of Liquid Nitrogen and Water in Perforated Structured Packing

Experimental Study on the Thermo-Hydrodynamic Characteristics of a Nitrogen Pulsating Heat Pipe

Numerical investigation on heat and mass transfer characteristics of ice slurry in pulsating flow

Development of a novel continuous nanofluid ice slurry generator: Experimental and theoretical studies

Study on ice slurry storing characteristics and its uniformity in ice storage tank