Abstract:In this study, a packed-bed dielectric barrier discharge reactor was built for the removal of biomass gasification tar. Two kinds of packing materials, glass pellets and a Ni/gamma-Al2O3 catalyst, were employed for the plasma-alone process and the plasma catalytic process, respectively. Toluene was used as the tar surrogate, and five typical gas combinations, N-2, N-2 + CO2, N-2 + CO2 + CO, N-2 + CO + H-2, and simulated gasification gas (SGG), were selected as carrier gases. The effects of the main components of the gasification gas on toluene removal under plasma and/or catalysis treatment were studied. The results indicated that the highest removal efficiency in the plasma-alone process was achieved in the N-2 atmosphere, and the addition of H-2, CO, or CO2 to N-2 led to a decrease in the removal performance. When Ni/gamma-Al2O3 was introduced into the plasma process, the best removal efficiency was obtained in the N-2 + CO2 atmosphere. However, the positive effect of CO2 on toluene removal switched to a negative effect when CO2 coexists with CO and H-2 in the gas mixture. In addition, both the terminating effect at low temperature and the occurrence of methanation induced by CO at high temperature could significantly inhibit the removal of toluene in the plasma catalytic process. Typically, in the SGG atmosphere, the highest toluene removal efficiencies under plasma-alone, catalysis-alone, and plasma catalysis treatments were 33.5, 38.6, and 92.5%, respectively. Furthermore, no CN-containing or O-containing compounds were identified as the major by-products in the plasma catalytic process, which is significantly different from what was observed in the plasma-alone process. Moreover, a detailed mechanism of toluene removal under plasma and plasma catalysis treatment was proposed after the analysis of gas and liquid products.

Removal of low-concentration BTX in air using a combined plasma catalysis system.

Removal of Dilute VOCs in Air by Post-Plasma Catalysis over Ag-based Composite Oxide Catalysts

Characteristics of Back Corona Discharge in a Honeycomb Catalyst and Its Application for Treatment of Volatile Organic Compounds.

Toluene Decomposition by a Two-stage Hybrid Plasma Catalyst System in Dry Air

Plasma Induced Toluene Decomposition on Alumina-Supported Mn-Based Composite Oxides Catalysts

Catalytic behavior and synergistic effect of nonthermal plasma and CuO/AC catalyst for benzene destruction

Benzene Removal Using Non-thermal Plasma with CuO/AC Catalyst: Reaction Condition Optimization and Decomposition Mechanism

Non-thermal plasma coupled with CM/Z5 catalyst for toluene removal

Plasma-catalytic oxidation of toluene over MCeZrO x /TiO 2 (M = Cu, Mn, Ni and Co) catalysts using a dielectric barrier discharge reactor

In Plasma Catalytic Oxidation of Toluene Using Monolith CuO Foam As a Catalyst in a Wedged High Voltage Electrode Dielectric Barrier Discharge Reactor: Influence of Reaction Parameters and Byproduct Control

Mechanisms of Toluene Removal in Relation to the Main Components of Biosyngas in a Catalytic Nonthermal Plasma Process

Post-plasma-catalytic Removal of Toluene Using MnO2–Co3O4 Catalysts and Their Synergistic Mechanism

Catalytic non-thermal plasma reactor operating at low applied voltage for the removal of toluene in air

Removal of benzene by non-thermal plasma catalysis over manganese oxides through a facile synthesis method

Removal of Toluene As a Biomass Tar Surrogate in a Catalytic Nonthermal Plasma Process

Non-thermal Plasma Catalysis for Chlorobenzene Removal over CoMn/TiO2 and CeMn/TiO2: Synergistic Effect of Chemical Catalysis and Dielectric Constant

Nonthermal plasma coupled with Mn/N-doped carbon catalysts for highly efficient removal of toluene

Enhancement of Flue Gas Low-Concentration Toluene Removal in Pulsed Plasma Coupling with Porous Ceramic Modified Catalyst Reactor

Simultaneous removal of toluene and styrene by non-thermal plasma-catalysis: Effect of VOCs interaction and system configuration

Highly Efficient Decomposition of Toluene Using a High-Temperature Plasma-Catalysis Reactor.

By-product reduction for the non-thermal plasma removal of toluene using an α-MnO 2 /Cordierite honeycomb monolithic catalyst in a honeycomb structure