Abstract:Recently, to achieve a stable slider dynamics and a high recording density, a contact (lubricant surfing) recording scheme has been proposed in the literature. However, under contact/surfing condition, the interaction between the head and the disk may bring new tribological issues, which has not been fully understood so far. To amend that, this paper experimentally investigates the relation between the interfacial dynamics and the wear behaviors of head/disk at different contact conditions. To investigate the interfacial dynamics, slider was then flown at different contact stages, and slider vibrations in both the vertical and the downtrack directions were monitored using two laser Doppler vibrometers. The wear depth of slider was inspected after the experiment to correlate interfacial dynamics at different contact stages. According to our results, a severe contact is not necessary to generate serious wear, which has strong correlation with the interfacial dynamics. Compared with the structure modes, the air-bearing modes were found to have a dominant impact on slider wear. Moreover, nonlinear vibration has a much more detrimental effect on the slider wear, although this type of vibration accompanies small amplitude at high-frequency band. This paper helps understand the wear mechanisms of slider under different slider/disk contact conditions, and thus expands new designs for surfing/contact recording technologies.

Particle Build-Up On Flying Sliders And Mechanism Study Of Disk Wear And Head-Disk Interface Failure In Magnetic Disk Drives

Hard-particle-induced physical damage and demagnetization in the head-disk interface

Surface Topology Optimization of Air Bearing Slider for Wear Durability in Magnetic Hard Disk Drives

Slider Dynamics and Wear Behaviors at Subnano-Clearance Head–Disk Interface

Wear Study For Dual-Heater Slider Under High Temperature

Simulation of Dynamic Behavior of Slider at Head/Disk Interface of Hard Disk Drives

Investigation of Electrostatically Tunable Adhesion and Instability of Flying Head Slider

Experimental Study of the Slider-Lube/Disk Contact State and Its Effect on Head-Disk Interface Stability

Experimental Study of Head-Disk Interface Flyability and Durability at Sub-1-nm Clearance

Microtribology of Hard Disk Drive for High Density Recording

Research on the Design and Fabrication of Air Bearing Sliders in Hard Disk Drives

Effect of Low-Frequency Vibration in Z-Direction (Out-of-Plane) on Slider Dynamics

Dynamic Character of Ultra Thin Film Gas lubrication for Magnetic Head/Disk

Nanoscale wear and kinetic friction between atomically smooth surfaces sliding at high speeds

Quantitative Identification of Slider Nanoscale Wear Based on the Head-Disk Interface Dynamics

Analysis of Pressure Distribution on Head Disk Air Bearing Slider Involved Van Der Waals Force

A flyability and durability dilemma in hard disk drives

Investigation of Contact Stiffness and Contact Damping for Magnetic Storage Head-Disk Interfaces

Numerical Simulation On Lubricant Recovery After Depletion

Flyability and Durability Test of Dynamic Fly-Height Sliders at 1-Nm Clearance

Simulation of Contact at Head and Multilayer Disk Interface under Quasi-Static Condition