Abstract:Catalytic hydrogenation of CO2 to methanol has attracted considerable attention due to its potential in alleviating global warming and mitigating the dependence on fossil fuels. Cu-based catalysts are widely used in industry because of their high activity for methanol production. However, the reaction still suffers from low methanol selectivity because of the generation of CO as a by-product via the reverse water gas shift reaction (RWGS). The formation of another by-product H2O leads to inevitable Cu sintering, which decreases the methanol production rate. It is well known that CO can alter competitive molecular adsorption on the surface and the redox behavior of the active sites; hence, CO doping in feed gas might not only inhibit the RWGS but also minimize surface poisoning by the adsorbed oxygen. On the other hand, CO2 hydrogenation to methanol over Cu-based catalysts is a structure-sensitive reaction, and a change in the precursor can have a remarkable influence on the structure and morphology of the catalyst, and ultimately, the catalytic performance. In this work, Cu/ZnO/Al2O3 catalysts have been prepared via a hydrotalcite-like precursor (CHT-CZA) and a complex phase precursor (CNP-CZA) using co-precipitation and ammonia evaporation methods. Subsequently, the performance of the two types of catalysts with different CO contents (CO2 : CO : H-2 : N-2 = x : (24.5 - x) : 72.5 : 3) is compared at 250 degrees C and 5 MPa in order to explore the role of CO. The evaluation results show that both catalysts follow a similar trend in the conversion of CO and CO2 as well as the space-time-yield (STY) of MeOH and H2O. The conversions of CO2 and STYH2O decrease gradually with an increase in the CO volume, but STYMeOH is positively correlated with the CO volume. Furthermore, X-ray photoelectron spectroscopy (XPS) analysis reveals that the amount of reduced Cu species on the surface increases with increasing CO content. Judging from these results, the introduction of CO inhibits the RWGS and enhances the methanol yield for both catalysts by removing the surface oxygen as the reducing agent and thereby facilitating the exposure of the active reduced Cu species. On the other hand, transmission electron microscopy (TEM) observations indicate the doped CO may cause agglomeration of particles due to over-reduction, leading to gradual catalyst deactivation. Compared with the traditional CNP-CZA, the catalyst derived from hydrotalcite-like compounds exhibits better activity and long-term stability under all atmospheres, at different CO doping levels. This is because the hydrotalcite-like layer structure helps maintain the active metal state and confine the structure by limiting the agglomeration of Cu species.

Low-temperature methanol synthesis catalyzed over Cu/γ-Al2O3–TiO2 for CO2 hydrogenation

Low-Temperature Methanol Synthesis Catalyzed Over Cu/Gamma-Al2o3-Tio2 For Co2 Hydrogenation

CO2 Methanation over TiO2–Al2O3 Binary Oxides Supported Ru Catalysts

Theoretical Investigation on the CO2 Hydrogenation to Methanol Mechanism at Electron-Rich Active Interface over Cu/Ga-Ti-Al-O Catalyst

Effect of Titanium on Methanol Synthesis from CO2 Hydrogenation over Cu/γ-Al2O3

RKCL3827 METHANOL SYNTHESIS BY CO2 HYDROGENATION OVER TITANIUM MODIFIED Γ-Al2o3 SUPPORTED COPPER CATALYSTS

Effect Of Titanium On Methanol Synthesis From Co2 Hydrogenation Over Cu/Gamma-Al2o3

The studies of methanol synthesis over the titanium-modified γ-alumina-supported CuO catalysts from CO2 hydrogenation

Methanol Synthesis from CO2 Hydrogenation over a Novel Titanium-Modified Γ-Al2o3 Supported Copper Catalyst

Promoting effect of titanium on Cu/γ-Al2O3 catalyst for CO2 hydrogenation

Methanol Synthesis from CO2 Hydrogenation over Copper Catalysts Supported on MgO-modified TiO2

Promoting effect of titanium on Cu/gamma-Al2O3 catalyst for CO2 hydrogenation

Methanol Synthesis from CO2 Hydrogenation over Supported CuO/TiO2 Catalysts

Hydrogenation of CO<sub>2</sub> to methanol over Cu/AlCeO catalyst

Methanol Synthesis by COx Hydrogenation over Cu/ZnO/Al2O3 Catalyst Via Hydrotalcite-Like Precursors: the Role of CO in the Reactant Mixture

Highly Efficient Cu/anatase TiO2 {001}-Nanosheets Catalysts for Methanol Synthesis from CO2

Methanol Synthesis from CO/CO_2 Hydrogenation over Cu/Zn/Al/Mn Catalyst

The influence of Mg/Al molar ratio on the performance of CuMgAl-x catalysts for CO2 hydrogenation to methanol

High-Performance Cu/ZnO/Al 2 O 3 Catalysts for CO 2 Hydrogenation to Methanol

Methanol synthesis from H2/CO/CO2 over CNTs-promoted Cu-ZnO-Al2O3 catalyst

Hydrogenation of CO2 to methanol over Cu/AlCeO catalyst