Abstract:Natural circulation served as an indispensable part of nuclear, attracted much more attentions in recent years. It does not need a pump to provide power. The operating principle of natural circulation caused its complexity in analysis process. It was still a difficult issue to reveal the law of natural circulation accurately. Many experiments and calculations had to be conducted to study the basic physical regulation. This paper concentrated upon the heat transfer characteristics in the test section with two different types of heat flux distribution. The two types of heating flux distribution in the test section were linear and chopped cosine along axial direction. Based on a natural circulation experimental facility, physical models and mathematic models were established. RELAP5 code was used to calculate the thermal hydraulic state of natural circulation loop. The variation of heat transfer coefficient along flow direction was different. It was tightly related to heat flux. Some relevant experiments were conducted in many different conditions and steady sate experimental data were achieved to verified theoretical calculations. Experimental data, such as water temperature, wall temperature and flow rate were recorded when the system is stable. The heat transfer coefficients were calculated according to the experimental data. The factors that affected the heat transfer characteristics of natural circulation were analyzed by comparing the heat transfer coefficient under different conditions. The heat transfer coefficient was calculated according to the empirical correlations as well.After a series of analysis, the results indicated heat transfer coefficient had an obvious difference, which influenced ability of natural circulation. Comparing with experimental data, the evaluation of different empirical correlations was conducted in two test sections. Some empirical correlations turned out to be suitable for the estimation of heat transfer in experiment facility. The increase of heat flux could enhance heat transfer process in the two test section under low pressure. Average heat transfer coefficient increased with the decrease of inlet subcooling degree. The system pressure effected the heat transfer characteristics of natural circulation as well. The increase of mass flux would promote heat transfer while the level was different. RELAP5 had a great agreement with experimental data in single phase flow. Natural circulation ability was influenced by the position of average heat source center, which was slightly different in the research objects. The research would lend strong empirical support to the guideline of experiment and subsequence study in natural circulation.

Natural circulation performance in a new cryogenic heat transfer unit

Simulation Test of Natural Circulation Precooling for Cryogenic Pump System

Influence Of Pressurization On Cooling-Down Process With A Gas-Phase Inlet Natural Circulation For A Cryogenic Pump System

Simulation and analysis of dynamic heat transfer inside a cryogenic valve under cryogenic test

Natural Circulation Precooling Experiment of Cryogenic Pump System

A NEW CRYOGENIC HEAT TRANSFER UNIT USED IN COOLING SUPERCONDUCTING MAGNET

Experimental Investigation on High Performance Cryogenic Heat Transfer Based upon Natural Circulation Cooling

Investigations on A Cryogenic Heat Transfer Unit Combining Natural Circulation Cooling and Two-Phase Closed Thermosyphon

Study of the Natural Circulation Flow Boiling Heat Transfer Based On Partially Superhydrophilic Surface Modification

Numerical investigation on cryogenic pulsating heat pipes with nitrogen

Experimental Study on Natural Circulation Precooling of Cryogenic Pump System with Gas Phase Inlet Reflux Configuration

Investigation On Heat Transfer Characteristics In The Test Section With Non-Uniform Heat Flux Distribution Under Natural Circulation

Numerical studies on natural circulation precooling loop of cryogenic liquid rocket engine

A Liquid Nitrogen Cooling Circulation Unit: Its Design and a Performance Study

Numerical and Experimental Investigations of the Static Characteristics of A Natural Circulation System at Nuclear Heating Reactor Conditions

Numerical Analysis on Natural Circulation Precooling of Cryogenic Liquid Rocket Engine

Numerical study of heat transfer characteristics of intermittent flow cold storage surface heat exchanger

Icone23-1025 experiment investigation on convection heat transfer in a heating tube on the natural circulation condition

Numerical study on natural convection heat transfer of fin-tube air-heating vaporizer

Theoretical and experimental investigation on heat transfer characteristics in a cryogenic two-phase closed thermosyphon

Experimental Investigation of Single-Phase Natural Circulation in a Mini-Loop Driven by Heating and Cooling Fluids