Abstract:In this work, carrier-phase direct numerical simulation (CP-DNS) is conducted for a pulverized coal flame in a temporally evolving turbulent jet with flue gas recirculation (FGR). Detailed gas phase kinetics are considered and heavy hydrocarbon molecules up to C20 are included to accurately represent tars in the volatile matter. The structure of the pulverized coal flame is analyzed with different flamelet models considering two mixing scenarios, namely the mixing of recirculated flue gases with the other fuel or oxidizer streams. In the first model approach, the mixing of recirculated flue gases with the gaseous fuels released from the coal particle is characterized with a fuel-split-based flamelet (FLT-FS) model. In the second approach, the mixing of flue gases with the transport air is described with an oxidizer-split-based flamelet (FLT-OS) model. In total, five trajectory variables are introduced in the flamelet table to represent the pulverized coal combustion states with FGR. The suitability of the flamelet models is evaluated through an a priori analysis for both the fully ignited state, as well as (more challenging) the igniting states. Comparisons show that both the FLT-FS model and the FLT-OS model perform well in predicting the thermo-chemical quantities for the fully ignited state. The FLT-OS model performs slightly better than the FLT-FS model in predicting the gas temperature and specific species mass fractions. This is due to the fact that the partial oxidization of the gaseous fuels by the hot flue gases outside the mixing layers cannot be reproduced by the FLT-FS model. While the state at the beginning of ignition can still be accurately predicted by the FLT-OS model, discrepancies can be observed for the tar species C20H10 and the intermediate species CO at a later stage when many particles ignite and the reason for this is explained. Further analysis in the flamelet solution spaces shows that the gaseous fuels are ignited on the fuel-lean side. The time evolution of the gas temperature from the beginning of ignition to the fully ignited state can be overall characterized by both flamelet models.

Modeling Research on the Burnout Characteristics of Fine Anthracite Char Particle in CFB Combustor

Modeling Research On Char Particle Combustion Behavior In Cfb Condition

Measurements and Modelling of Oxy-Fuel Coal Combustion

A general mechanistic model of fly ash formation during pulverized coal combustion

Research on the Burnout of Fujian Anthracite in Cfb Boiler

Research on Dynamic Model of CFB Combusting Anthracite Coal

Factors Influencing the Burn-Out Rate of Fujian Anthracite Coal in CFB Boilers

Reduced-order model of char burning for CFD modeling

Mathematical modeling of combustion in a grate-fired boiler burning straw and effect of operating conditions under air- and oxygen-enriched atmospheres

The Influence of Coal Particle Diameter on the Burning-Out of Anthracite in CFB Boiler

Modelling the Combustion of Thermally Thick Biomass Particles

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

Computational modeling of oxy-coal combustion with intrinsic heterogeneous char reaction models

Postcombustion and Its Influences in 135 Mwe Cfb Boilers

MODELLING PULVERISED COAL COMBUSTION USING A DETAILED COAL COMBUSTION MODEL

Flame Structure Analysis and Flamelet Modeling of Turbulent Pulverized Solid Fuel Combustion with Flue Gas Recirculation

Discrete Ash Inhibition Model of Char Burning for the CFD Modeling of Precalciner

ANALYSIS OF BURNOUT BEHAVIOR FOR ANTHRACITIC COAL

One-dimensional Mathematical Model and Relevant Simulation for Pulverized Coal Combustion in a Boiler Furnace

Heat Transfer in the Rotary Ash Cooler with Residual Char Combustion Considered

Unburned Carbon Loss in Fly Ash of CFB Boilers Burning Hard Coal