Abstract:Most wastewater treatment reactors have problems such as slow start-up and a poor treatment effect. This study investigates the rapid start-up and optimal conditions of the expanded granular sludge bed (EGSB)–two-stage anaerobic/aerobic (A/O) biofilm process. The combined process was successfully started by gradually increasing the organic load for approximately 50 d, during which the organic loading rate increased from 4.6 to 46 kg·COD/(m3·d). By investigating the operation effect of the EGSB reactor at hydraulic retention times (HRTs) of 4, 6, 8, and 10 h, reflux ratios of 6:1, 7:1, 8:1, and 9:1, and ammonia concentrations of 200–800 mg/L, the optimal operation conditions were determined. In the two-stage A/O process, hollow cylindrical fillers and hollow spherical fibrous fillers were used to observe the growth of biofilms on different fillers. The sludge structure and microorganisms were analyzed by scanning electron microscopy and high-throughput sequencing. The results show that when the combined process was successfully started, the chemical oxygen demand removal rate was 97%, and the ammonia nitrogen removal rate was 73%. The EGSB reactor had the best operation effect under the conditions of a low ammonia concentration, HRT = 8 h and reflux ratio of 8:1. In the two-stage A/O process, the biofilm growth condition of the hollow column filler with a high specific surface area was better than that of the hollow spherical filler containing flocculent fibers. The microstructure of the sludge was conducive to the metabolism of microorganisms. The primary microorganisms at the phylum level mainly included Proteobacteria, Firmicutes, Synergistetes, Actinobacteria, and Chloroflexi. These findings provide a new idea for the treatment of high-concentration organic wastewater and reactor start-up.

STUDY ON THE START-UP IN AEROBIC MOVING-BED MULTI-STAGE AO BIOFILM REACTOR

Synergistic Effect of Chitosan-Based Sludge Aggregates CS@NGS Inoculum Accelerated the Start-Up of Biofilm Reactor Treating Aquaculture Effluent: Insights into Performance, Microbial Characteristics, and Functional Genes.

Start-up Evaluations and Biocarriers Transfer from a Trickling Filter to a Moving Bed Bioreactor for Synthetic Mariculture Wastewater Treatment.

Studies on Start-Up Technique of Anammox Bioreactor

[Performance of ANAMMOX Attached Microbial Film Expanded Bed Reactor].

Aquaculture wastewater treatment using a moving bed biofilm reactor( MBBR)

Study on Start-up and Operation of Anaerobic Attached Film Expanded Bed with Resin As Biofilm Carrier

Low strength wastewater anammox start-up by stepwise decrement in influent nitrogen: Biofilm formation mechanism and mathematical modelling.

Characterization and Quantification of Anammox Start-Up in UASB Reactors Seeded with Conventional Activated Sludge

[Start-Up and Process Control of a Pilot-Scale Anammox Bioreactor at Ambient Temperature].

[Performances of Anammox-Egsb Bioreactors Started Up with Three Different Seeding Sludges].

Advanced start-up of anaerobic attached film expanded bed reactor by pre-aeration of biofilm carrier.

Start-up of Anammox Bioreactor with Denitrification Biofilm

Seeding Sludge and Start-up Strategy for Anammox Bioreactor

Study on the start-up operation and sludge characteristics of organic wastewater treated by the EGSB–two-stage anaerobic/aerobic biofilm process

Investigation on Start-Up and Operation of an Anaerobic Attached Microbial Film Expanded Bed with Ceramisites As Biofilm Carrier

Influence of Inoculated Sludge Quantity on Start-up of Hybrid Biofilm Reactor

Study on Start-Up and Running of ANAMMOX Reactor

Study on start-up processes of two-stage biological aerated filter

Start-up of Anaerobic Ammonia Oxidation Bioreactor with Nitrifying Activated Sludge.

Improvement of start-up and nitrogen removal of the anammox process in reactors inoculated with conventional activated sludge using biofilm carrier materials