Abstract:Silicon dioxide films have been deposited by plasma-enhanced chemical vapor deposition at low substrate temperature (50 °C) in a parallel-plate reactor using hexamethyldisilazane (HMDS), diluted in He, and O2 as Si and O precursors. The effect of the O2/(HMDS+He) flow rate ratio on the oxide properties has been investigated in the range of 0.05–1.25 by means of deposition rate, wet etching rate, secondary ion mass spectrometry, thermally stimulated luminescence, and high frequency capacitance–voltage measurements. Both the deposition rate and the etching rate increase by increasing the O2/(HMDS+He) flow rate ratio and reach a constant value at flow rate ratios higher than 0.6. The strong increase and saturation in the deposition rate can be attributed to the impinging oxide atoms flux and to the consumption of silyl radicals at the deposition surface, respectively. The Si/SiO2 interface state density and the positive fixed charge density are in the range 1×1011–1×1012eV−1 cm−2 and 6×1011–1.5×1012C cm−2, respectively. These concentrations are comparable with literature data concerning SiO2 films obtained by plasma enhanced chemical vapor deposition at temperatures higher than 200 °C using other Si precursors. Moreover, the interface state density decreases while the fixed oxide charge increases by increasing the O2/(HMDS+He) flow rate ratio. A correlation has been found between defects monitored by thermally stimulated luminescence and fixed oxide charges. From a comparison with secondary ion mass spectrometry results, the fixed oxide charges can be preliminarily attributed to intrinsic defects.

Low Dielectric Constant SiO2:C,F Films Prepared from Si(OC2H5)4/C4F8/Ar by Plasma-Enhanced CVD

Preparation Of Low-K Nanoporous Sio2 Films By Plasma-Enhanced Chemical Vapor Deposition

Thickness Dependence of Properties of Plasma-Deposited Amorphous SiO2 Films

An amorphous SiCOF film with low dielectric constant prepared by plasma-enhanced chemical vapor deposition

Structure characterization of carbon and fluorine-doped silicon oxide films with low dielectric constant

Deposition of Dense SiO2 Thin Films for Electrical Insulation Applications by Microwave ECR Plasma Source Enhanced RF Reactive Magnetron Sputtering

Preparation and characterization of low-dielectric-constant F-doped SiOCN films by PECVD

Low-dielectric-constant Α-Sicof Film for ULSI Interconnection Prepared by PECVD with TEOS/C4F8/O2

Plasma enhanced chemical vapor deposition ultralow dielectric constant films using triethoxymethylsilane and limonene as precursors

Synthesis and characterization of SiCOF/a-C:F double-layer films with low dielectric constant for copper interconnects

Porous Amorphous Fluoropolymer Films with Ultralow Dielectric Constant

Synthesis and Characterization of SiCOF/ a2C∶F Double2Layer Films with Low Dielectric Constant for Copper Interconnects

Carbon - Silicon Heterojunction Diodes Formed by CH4/ Ar Rf Plasma Thin Film Deposition on Si Substrates

Characterization of PECVD ultralow dielectric constant porous SiOCH films using triethoxymethylsilane precursor and cinene porogen

Atomistic Simulation of plasma enhanced chemical vapor deposited SiCOH dielectrics

SiO2 films deposited on silicon at low temperature by plasma-enhanced decomposition of hexamethyldisilazane: Defect characterization

Effect of O2-doping on Bonding Configuration and Electric Properties of SiCOH Films Prepared by Decamethylcyclopentasiloxane Electron Cyclotron Resonance Plasma

Improved electrical characteristics of 4H-SiC (0001) MOS devices with atomic layer deposited SiO2 gate dielectric with H2O plasma

Preparation and structure of porous dielectrics by plasma enhanced chemical vapor deposition

A comparative study of Cx(x = 4, 5, 7)F8 plasmas for dry etch processing

FTIR Analyses of SiOF Thin Film with Low Dielectric Constant