Abstract:Fuel stratification has the potential to extend the high load limits of homogeneous charge compression ignition (HCCI) combustion by improving the control over the combustion phase as well as reducing the maximum rate of pressure rise. In this work, experiments were carried out on a single-cylinder engine equipped with a dual-fuel-injection system – a port injector for preparing a homogeneous charge and a direct in-cylinder injector for creating the desired fuel stratification. The homogeneous charge was prepared using gasoline fuel while the fuel stratification was created with the in-cylinder injection of either gasoline or methanol during the compression stroke. The test results indicate that high load extension using gasoline for fuel stratification is limited by the trade-off between CO and NO x emissions. Weak gasoline stratification leads to an advanced combustion phase and an increase in NO x emission, while increasing the stratification with a higher quantity of gasoline direct injection, results in a significant deterioration in both the combustion efficiency and the CO emission. Engine tests using methanol for the stratification retarded the ignition timing and prolonged the combustion duration, resulting in a substantial reduction in the maximum rate of pressure rise and the maximum cylinder pressure – a prerequisite for HCCI high load extension. Further tests were then conducted with methanol stratification to extend the HCCI load limit and to optimize the stratified methanol-to-gasoline fuel ratio. Compared to gasoline HCCI, a 50% increase in the maximum IMEP attained was achieved with an acceptable maximum pressure rise rate of 0.5 MPa/°CA while maintaining a high thermal efficiency.

Experimental Investigation on Extending Load Range of Diesel HCCI Engine by Internal EGR and Boost

Potential of High Load Extension for Gasoline Hcci Engine Using Boosting and Exhaust Gas Recirculation

Extending HCCI High Load Operation of Gasoline Engine by Intake Boosting

External EGR Combined with Internal EGR for High Load Extension on a Gasoline HCCI Engine

Experimental Research on High Load Extension of HCCI Combustion Using Gasoline and Methanol Stratification

Extension of the Lower Load Limit in Dieseline Compression Ignition Mode

Experimental Research on the Effects of Exhaust Gas Recirculation Strategy on Stoichiometric Spark Induced Compression Ignition Combustion

Numerical Modeling of Diesel Engine Combustion and Emissions Under HCCI-Like Conditions With High EGR Levels

Numerical study of stratification on HCCI combustion for higher load extension

Numerical Study of Charge Stratification on Load Extension of Gasoline HCCI

Research on low temperature combustion of homogeneous charge induced ignition (HCII) in a light-duty diesel engine

Experimental Research on HCCI Using Gasoline and Diesel Blended Fuels

Experimental study of fuel stratification for HCCI high load extension

Experimental Investigation of Homogeneous Charge Induced Ignition (hcii) with Low-Pressure Injection to Reduce Pm Emissions in A Heavy-Duty Engine

Experimental investigation on the combustion and emissions in a pilot ignited direct injection natural gas engine using HCDI strategy

Experimental Study on the Diesel Injection Pressure of Homogeneous Charge Induced Ignition for Multi-cylinder Operation

Experimental study of independent two-stage in-cylinder heat release using jet controlled compression ignition

HCCI combustion control by injection strategy with negative valve overlap in a GDI engine

Experimental study on the combustion and emission performance of the hydrogen direct injection engine

Experimental investigation on emission characteristics of high reactivity gasoline compression ignition with different EGR and injection pressure strategies

Combustion and Emission Characteristics of an Electronically-Controlled Common-Rail Dual-Fuel Engine