Abstract:Accurate prediction of the heat transfer performance in tight rod bundles is important for the design and safety analysis of supercritical water-cooled reactors (SCWRs). However, the error of the current correlations for predicting supercritical heat transfer coefficient in rod bundle and grid spacer is large under certain conditions. In the present paper, an experimental study of heat transfer to supercritical water in a three-rod bundle with spacer grids is carried out at Shanghai Jiao Tong University. The rod bundle is composed of three heated rods and three unheated rod-like fillers with an outer diameter of 15 mm and a pitch-to-diameter ratio of 1.2. Honeycomb grid spacers with a blockage ratio of 0.158 are equipped in the bundle. The system pressure is 23 MPa and the mass flux ranges from 800 to 1600 kg/(m(2).s). Moreover, the heat flux varies from 400 to 700 kW/m(2) and the fluid temperature is in the range of 285-382 degrees C. Wall-temperature gradients are observed along the circumference direction of heated rods. The wall temperature is higher in the gap area between heated rods and it is lower in the cold-wall area. When approaching the pseudo-critical point, the non-uniformity of the wall temperature is significantly reduced. Six existing correlations for fully-developed heat transfer at supercritical pressure are assessed against the experimental data, among which the Bishop correlation gives the best predictions. A new correlation is developed based on the experimental data and most of them are predicted within +/- 15% with a mean absolute deviation of 6.0% and a root-mean-square deviation of 7.3%. The enhancement ratios of heat transfer downstream of spacers are substantially under-predicted by the commonly used correlations. Based on the observation that the maximum enhancement ratio increases linearly with the Reynolds number in pseudo-liquid regions, a new correlation is proposed to predict the heat transfer augmentation downstream of spacers, correlating most of the data within +/- 20% with a mean absolute deviation of 6.2% and a root-mean-square deviation of 8.4%.

A New Heat Transfer Correlation for Supercritical Fluids

A Method of Extending Subcritical Heat Transfer Correlations to Supercritical Conditions

A New Correlation For Heat Transfer Coefficient Prediction Of Supercritical Pressure Water Flowing In Vertical Upward Tubes

Reference temperature correction and dimensionless number analysis for heat transfer of supercritical CO2 in horizontal tubes

A New Prediction Method for Heat Transfer to Supercritical Fluids Based on Predictive-Corrective Technique

Assessment of Heat-Transfer Correlations Against Experimental Data Obtained with Supercritical Water in Vertical Annuli

An Improved Heat Transfer Correlation for Supercritical Aviation Kerosene Flowing Upward and Downward in Vertical Tubes

A New Heat Transfer Correlation for Supercritical RP-3 Flowing in Vertical Tubes

Wide-ranged Heat Transfer Correlations of Supercritical Water in Vertical Upward Channels

A Dimensionless Correlation to Predict the Onset of Heat Transfer Deterioration of Supercritical Fluids in Upward Circular Tubes

General Heat Transfer Correlations for Supercritical Carbon Dioxide Heated in Vertical Tubes for Upward and Downward Flows

Predictions of Heat Transfer Coefficients and Pressure Drops to Supercritical Pressure Hcfc22 Flowing in A Small Tube

Development of Heat Transfer Correlation for Supercritical Water in Vertical Upward Tubes

Correlation evaluation on circumferentially average heat transfer for supercritical carbon dioxide in non-uniform heating vertical tubes

Review of heat tranfer correlations for water under supercritical pressure

Nonuniform Heat Transfer of Supercritical Water in a Tight Rod Bundle – Assessment of Correlations

Experimental Investigation on Heat Transfer to Supercritical Water in a Three-Rod Bundle with Spacer Grids

A New Modeling Method to Evaluate Effective Forced-Convective Heat Transfer Rate of Pipe Flow with Endothermic Chemical Reactions

Discussion and perspectives for improvements of heat transfer correlation capabilities for fluids at supercritical pressures

A New Correlation for Post-Dryout Heat Transfer in Upward Vertical Flow

New correlation of the subcooled flow boiling heat transfer coefficient for hybrid micro/nanostructured surfaces with high heat flux incidence