Abstract:The quasi-square-wave (QSW) zero-voltage-switching (ZVS) symmetrical dual-buck H-bridge (DBHB) all-GaN inverter has been proven to have high efficiency and high density in Google's Little Box Challenge. This variable frequency QSW ZVS inverter is drawing more and more interest in the industry and academia. However, the ac current control with cycle-by-cycle variable frequency ZVS operation is a basic challenge for this inverter. The conventional control methods for this QSW ZVS inverter, such as the hysteresis current mode control and the variable on-time control, require high-speed current sensing or zero-crossing detection (ZCD) circuits, which are very sensitive to noises. In this article, achieving variable frequency average current mode control with variable frequency pulsewidth modulation (VFPWM) is discussed and implemented for this QSW ZVS inverter to eliminate high-speed current sensing or ZCD circuits. For any synchronous half-bridge type converter, the voltage conversion ratio is dependent only on the duty-cycle in either continuous conduction mode (CCM) or QSW ZVS mode. The frequency of the PWM triangular carrier is another degree of freedom. In this control method, the averaged inductor current is sensed and regulated by the average current mode feedback controller and the duty-cycle is generated by the average current controller. The frequency of the PWM carrier is variable and directly calculated based on the duty-cycle signal and the sensed and filtered voltage and current signals. Since all the sensed signals for this current controller are low speed and filtered signals, this current control is highly immune to noises. The reliability of ZVS for this inverter is improved. The complexity of the controller is also reduced. A detailed analysis of the QSW ZVS conditions for the full range operation of the symmetrical DBHB inverter is done in this article. More negative currents can be introduced to reduce the switching frequency and increase the reliability of ZVS. A frequency limiter helps limit the frequency when the current is close to zero or under light load conditions. A frequency updating method with a constant and low interrupt frequency in a digital controller is also discussed. Finally, to verify this control method, a 1-kW all-GaN DBHB inverter prototype is developed and tested in this article.

Current-mode Variable-Frequency Control Architecture for High-Current Low-Voltage DC–DC Converters [Letters]

A Novel Current Mode Variable Frequency Control For Dc-Dc Converters With Adaptive Voltage Positioning

Design and Simulation of a PFM-PWM Hybrid Controller for DCDC Converter with CLLC Topology

Design Of A Cmos Integrated Controller With Variable Switching Frequency For High Current Low Voltage Dc-Dc Converters

Minimum Current Control for Under-Resonant Dual-Bridge-Series-Resonant Converter

A High-Performance PWM Controller with Adjustable Current Limit

Overcoming High Frequency Limitations of Current-Mode Control Using a Control Conditioning Approach -- Part I: Modeling and Analysis

A Novel CCSC for Circulating Current Suppression in Modular Multilevel Converters

A Modified Y-Source DC–DC Converter with High Voltage-Gains and Low Switch Stresses

Overcoming High Frequency Limitations of Current-Mode Control Using a Control Conditioning Approach -- Part II: Implementation and Hardware

A Novel Modulation Scheme and a DC-Link Voltage Balancing Control Strategy for T-Type H-Bridge Cascaded Multilevel Converters

Closed-Loop Decoupled Control and Implementation of the Modular Multilevel Matrix Converter in Similar/Equal Frequency Operation

An Optimal Peak Current Mode Control Scheme for Critical Conduction Mode (crm) Buck Pfc Converter

Variable Frequency Average Current Mode Control for ZVS Symmetrical Dual-Buck H-Bridge All-GaN Inverter

Variable Structure Approaches for Current Control in Vector Controlled Inverter-Induction Motor System.

A Novel Constant Current Control Strategy with Seamless Switching Between CC and CV

Design of a constant-voltage and constant-current controller with dual-loop and adaptive switching frequency control

A Hysteresis Current Controller for Single-Phase Three-Level Voltage Source Inverters

A Low-Cost Constant Current Control Method for DCM and CCM in Digitally Controlled Primary-Side Regulation Flyback Converter

A Control Strategy and Design Method for Interleaved LLC Converters Operating at Variable Switching Frequency

A Class of Control Strategies Based on Bias Current Decouple for High Precision Current Converter