Abstract:The micro-structure and photocatalytic activity of natural rutile, which was heated and annealed under hydrogen atmosphere, was studied here. Several conventional mineralogical test methods were used, such as X-ray diffraction (XRD), environmental scanning electron microscopy (ESEM), UV-vis diffusive reflectance absorption spectral analysis and structural refinement using GSAS software with Rietveld method. The natural rutile samples used in this study are found in a metamorphic deposit and collected from Shanxi province, China. The experimental results indicate that V, Fe and other impurities exist in the crystal lattice of natural rutile as isomorphous substitution for Ti ions, which causes distortion of crystal lattice and effectively enhances the photocatalytic activity of the specimens. As the temperature increased, parts of the isomorphous substituted ferric ions were gradually reduced to divalent and elemental iron. On one hand, the unit cell parameters of rutile decreased because of escaping of ions from the lattice, which have larger ionic radii than Ti 4+ ion. On the other hand, the unit cell parameters would be increased because of thermal expansion caused by the heat treatment. Therefore, no significant change in the unit cell parameters was observed. At the same time, the visible light response abilities of heated rutile samples were largely improved with increasing temperature. Compared to the original sample RZM, the light absorption intensity of sample, which was subjected to heat treatment at 900℃, was enlarged by 147.2 % at 600 nm. Rietveld refinements suggested that a small amount of simple substance iron appeared when the heating temperature reached 800 ℃ and 900 ℃. Iron is a metallic conductor and has lower Fermi level.When iron was in contact with semiconductor rutile particles, the photo-induced electrons could be transferred rapidly, thereby enhancing the visible light response ability of the system.

The Effects of Argon Heat Treatment on the Response of Visible Light to Natural Rutile

The Micro-Structure Study of Natural Rutile Modified by Heat Treatment

Effects of Hydrogen Heat Treatment on the Visible Light Absorption of Natural Rutile

The Crystal Structure and Photocatalytic Activity of Natural Rutile Modified by Heat Treatment

Enhanced visible-light response of natural V-bearing rutile by annealing under argon

EFFECTS OF HEAT TREATMENT ON FAR-INFRARED EMISSIVITY OF TOURMALINE

Effect of Heat Treatment on the Properties of Nano-Diamond under Oxygen and Argon Ambient

Effects of Heat-Treatment Temperature on Preparation of the Sol-Gel-Derived Ag/TiO2 Films

Photocatalysis of V-bearing rutile on degradation of halohydrocarbons

Low‐Temperature Growth of Rutile Nanorod Thin Films and Their Photon‐Induced Property

Effect of Rapid Thermal Annealing Ambient on Photoluminescence of Zno Films

The Effect of Fe on Stability of Hydrogen Defects in Rutile

Effects of heat treatment temperature on up-conversion luminescence properties of titania/γ-glycidoxypropyltrimethoxysilane composite thin films dispersed with neodymium oxalate nanoparticles

Effect of Heat Treatment Atmosphere on the Structure and Apatite-Inducing Ability of Ca, P, Si and Na Incorporated Microarc Oxidation Coating on Titanium

Effect of Annealing on the Properties of Nano-diamond under Argon Ambient

Influence of Treated Temperature on Photocatalytic Ability of Anatase TiO2 and Degradation of Methyl Violet Dyestuff Using Visible Light

Effect of heat treatment on the emission rate of radon from red sandstone

Influence of heat-treating temperature upon the light absorption for commercial CuCr2O4

Heat Treatment During Preparation of Nano-zirconia Powders by the Liquid-phase Process

Chemical and Spectral Variations between Untreated and Heat-Treated Rubies from Mozambique and Madagascar

Effect of Heat Treatment on Properties of HfO2 Film Deposited by Ion-Beam Sputtering