Abstract:Suspensions were prepared by mixing hydrophilic fumed silica (FS) with low-molecular polyethylene glycol (PEG, weight-averaged molecular weight 400). By differential scanning calorimeter and broadband dielectric spectrometer, influences of FS volume fraction (phi) on alpha-relaxation and crystallization behaviors of bulk PEG phase were investigated. Furthermore, influences of phi on the linear and nonlinear rheology behaviors of the suspensions were also investigated using stress-controlled rheometer. For the bulk PEG phase, alpha-relaxation is retarded and glass transition temperature (T-g) is increased due to the addition of FS. On the other hand, FS significantly retard the diffusion of global PEG molecules, which leads to a great increase in viscosity of the suspensions along with significant reductions in crystallization and fusion enthalpy of the bulk PEG phase. The suspensions demonstrate different rheology and crystallization behaviors with varying phi. The low-filled suspensions exhibit an apparent sol-like rheological response, in which FS plays a nucleating role to promote PEG crystallization. However, the high-filled suspensions apparently behave like gels, in which FS restrains the chain diffusion and crystallization. The role of FS changes in the vicinity of phi = 0.16, where the system undergoes an apparent sol-to-gel transition. In the close vicinity of this transition, the nonlinear dynamic rheology shows the most obvious strain hardening, while the linear dynamic rheology demonstrates the most significant frequency-dependence. Due to the extremely complicated nonlinear rheological response of the suspensions, it is hard to observe the pure hydrodynamics region experimentally, and in the frequency range achieved, complex viscosity (eta*) as a function of phi at given frequencies does not fit classical hydrodynamics equations that do not consider the effect of nanoparticles on the polymer chains diffusion. To account for the effect of nanoparticles on the diffusion of PEG chains, data of liner dynamic rheology of the suspensions are shifted horizontally and vertically to create master curves with pure PEG as the reference. The creation of master curves reveals that FS greatly retards the diffusion of global PEG chains in the constrained bulk phase, which plays a major role in the reinforcement and dissipation of the suspensions. In addition to the dynamically retarded bulk PEG chains, both the inter-particle friction in the low-filled sols and the in-cage rattling motion of nanoparticles in the high-filled gels additionally contribute to the dissipation behavior of the suspensions, resulting in the complicated dynamic rheological behavior.

Effects of PEG Concentration and Temperature on the Rheological and Thermodynamic Properties of PSF Casting Solution

The Polymer-rich Phase Solidification Process of PVDF-PVP-DMAc-H2O Solution

Rheological and thermodynamic variation in polysulfone solution by PEG introduction and its effect on kinetics of membrane formation via phase-inversion process

Effect Of Polyethersulfone On The Mechanical And Rheological Properties Of Polyetherimide-Modified Epoxy Systems

Rheological Study of Epoxy Systems Blended with Poly(ether sulfone) of Different Molecular Weights

Influence of additives on phase separation process of PVDF solution and membrane morphology

Effect of the Casting Solvent on the Crystal Characteristics and Pervaporative Separation Performances of P(Vdf-Co-Hfp) Membranes

Effects of Poly(ethylene Glycol) Molecular Weight on the Stability of Surfactant-Free Emulsion Polymerization System Consisting of Styrene and Methyl Methacrylate

Effect of Polyethlene Glycol on Membrane Forming Systems and Polyethersulfone with Cardo Performance and Structure

Influence of different non-solvent additives to the casting solution on the structure and properties of PES membranes

Preparation of Casting Solutions for Poly (phthalazinone Ether Ketone) Ultrafiltration Membrane

The Effect of Polyethylene Glycol on Formation Kinetics of Membrane Formation Via Phase-Inversion Process

Effect of Zero Shear Viscosity of the Casting Solution on the Morphology and Permeability of Polysulfone Membrane Prepared Via the Phase-Inversion Process

Molecular Relaxation and Rheological Behaviors of Fumed Silica/Low-molecular Weight Polyethylene Glycol Suspensions

Effects of TEP-DMAc Mixed Solvent on Performances of PVDF Membranes

Preparation and Characterization of PSf Microporous Membranes by PSf-DMAc-PEG Systems with Low Critical Solution Temperatures

Effect of PEG additive on the morphology and performance of polysulfone ultrafiltration membranes

Influence of PEG-PPG-PEG Block Copolymer Concentration and Coagulation Bath Temperature on the Structure Formation of Polyphenylsulfone Membranes

Evaluation of solubility parameters and relative energy difference (RED) on the preparation of polysulfone/polyethylene glycol membrane: A study on the casting solution and coagulation bath

Preparation And Characterization Of Polysulfone Ultrafiltration Membrane With Peg As An Additive

Casting solvent effects on molecular dynamics of weak dynamic asymmetry polymer blend films via broadband dielectric spectroscopy