Development of novel dechlorination sorbent for the regeneration stream from catalytic reforming unit and study on its adsorption behavior in the fixed bed reactor

Liu Xibiao,Shen Benxian,Li Cuilan,Li Lin

DOI: https://doi.org/10.3969/j.issn.1009-0045.2007.04.004

2007-01-01

Abstract:The adsorption performance of homemade dechlorination sorbent for HC1 gas was studied in a fixed bed reactor,compared with dechlorination sorbent T 411Q,and the effects of different experimental conditions on the breakthrough chlorine content of them were examined and discussed.The results showed that the homemade dechlorination sorbent could remove HCl gas volume fraction in regeneration stream to below 1.0×10-6 at 300~550 ℃;The change of HCl gas volume fraction within(1.0~2.0)×10-3 had little effect on the performance of homemade dechlorination sorbent;The smaller of the particle size of dechlorination sorbent,the greater of its breakthrough chlorine content;With space hourly velocity increasing,breakthrough chlorine content of the dechlorination sorbent displayed downward trend,however,when the space hourly velocity changed from 1000h-1 to 3000h-1,the breakthrough chlorine content varied insignificantly;The breakthrough chlorine content of homemade dechlorination sorbent was 24%~40%higher than that of T 411 Q under the condition of 450℃,space hourly velocity 2500h-1 and HCl gas volume fraction 2.0×10-3.The bed chlorine content distribution equation for the reaction between homemade dechlorination sorbent and HCl gas was obtained by simplifying the dechlorination behavior in fixed bed,and the breakthrough chlorine content of calcium based high temperature dechlorination sorbent could be predicted in different bed depths at different time according to the equation.