Abstract:The transformation-assisted consolidation under pressure has been demonstrated to be a promising method to fabricate the nano or submicron polycrystalline ceramic materials. The high pressure suppresses the long-range diffusion of the atoms and, consequently, restrains the grain coarsening. The new phases produced at high pressure could show finer grains under the appropriate thermodynamic conditions, which are not subject to the grain size of the raw materials. Ceramic materials exhibit the existence of the transformations under certain thermodynamic conditions and the formation of new phases generally undergoes the nucleation and growth. In the present work, monoclinic microcrystal ZrO2 with average grain size of 2 µm and Y2O3 with average grain size of 50 nm were mixed in molar ratio of 97∶3. The preparation of the samples was carried out by sintering at 5.5 GPa and temperatures of 800–1700 °C using the high pressure cubic cell, and the sample characterization was performed via the X-ray diffraction, scanning electron microscope and transmission electron microscopy. It was found that the monoclinic and submicron tetragonal composite polycrystalline ZrO2 in bulk is obtained under high pressure and high temperature. The average grain size of tetragonal ZrO2 fabricated at 1200, 1400, 1600 and 1700 °C is (145±62) nm, (246±165) nm, (183±62) nm and (245±107) nm, respectively. The synthesis of the fine-grained polycrystalline materials by the transformation under high pressure can solve the problems of agglomeration, adsorption and grain coarsening caused by the nanopowders as the starting materials in the conventional approach, which would be an alternative route to fabricate the fine-grained polycrystalline materials with the enhanced performances.

Structural Transition of Nanometer SiO2 Powders under High Pressure and High Temperature

EXPERIMENTAL STUDY ON THE PHASE RELATIONS OF THE SYSTEM Mg2SiO4-MgAl2O4 AT HIGH PRESSURE AND HIGH TEMPERATURE

Synthesis of Nano-Polycrystalline Coesite under High Temperature and High Pressure

Crystallization Behavior of Amorphous Si2bc3n Ceramic Monolith Subjected to High Pressure

Fabrication of Submicron Tetragonal Polycrystalline ZrO2 by the Transformation of Micro Monoclinic ZrO2 under High Pressure

Unraveling microstrain-promoted structural evolution and thermally driven phase transition in <i>c</i>-Sc<sub>2</sub>O<sub>3</sub> nanocrystals at high pressure

Characterization of the Interface Region During the Agglomeration of Silicon Nanocrystals in Silicon Dioxide

Pressure-induced structural transition in CaF2 nanocrystals

High-pressure Crystal Chemistry and Amorphization of Α-Quartz

PHASE TRANSFORMATION OF NaAlSiO_(4) AT HIGH-PRESSURE AND HIGH-TEMPERATURE AND X-RAY DIFFRACTION STUDY OF CALCIUM-FERRITE-TYPE NaAlSiO_4

Structural and mechanical properties of magnesium aluminate nanoceramics under high pressure

Phase Transformation in Nanocrystalline Alpha-Quartz Geo2 Up to 51.5 Gpa

Pressure-Induced Phase Transition and Compression Properties of HfO 2 Nanocrystals

Structural Characteristics and Elasticities of Coesite and Coesite-Ii at High Pressure

Advances in the study of phase transformation of silica under high pressure

Melting and Subsolidus Relations of SiO2 at 9–14 GPa

Wurtzite-to-Rocksalt Structural Transformation in Nanocrystalline CoO

In Situ Phase Transition Study of Nano- and Coarse-Grained Tio(2) under High Pressure/Temperature Conditions

Pressure-induced Structural Modulations in Coesite

High-Pressure Behavior of Sno2 Nanocrystals

High-pressure Raman spectroscopy study of α-quartz-like Si1-xGexO2 solid solution