Abstract:Ni nanoparticles supported on ZrO2 are a prototypical system for reforming catalysis converting methane to synthesis gas. Herein, we examine this catalyst on a fundamental level using a 2-fold approach employing industrial-grade catalysts as well as surface science based model catalysts. In both cases we examine the atomic (HRTEM/XRD/LEED) and electronic (XPS) structure, as well as the adsorption properties (FTIR/PM-IRAS), with emphasis on in situ/operando studies under atmospheric pressure conditions. For technological Ni-ZrO2 the rather large Ni nanoparticles (about 20 nm diameter) were evenly distributed over the monoclinic zirconia support. In situ FTIR spectroscopy and ex situ XRD revealed that even upon H2 exposure at 673 K no full reduction of the nickel surface was achieved. CO adsorbed reversibly on metallic and oxidic Ni sites but no CO dissociation was observed at room temperature, most likely because the Ni particle edges/steps comprised Ni oxide. CO desorption temperatures were in line with single crystal data, due to the large size of the nanoparticles. During methane dry reforming at 873 K carbon species were deposited on the Ni surface within the first 3 h but the CH4 and CO2 conversion hardly changed even during 24 h. Post reaction TEM and TPO suggest the formation of graphitic and whisker-type carbon that do not significantly block the Ni surface but rather physically block the tube reactor. Reverse water gas shift decreased the H2/CO ratio. Operando studies of methane steam reforming, simultaneously recording FTIR and MS data, detected activated CH4 (CH3 and CH2), activated water (OH), as well as different bidentate (bi)carbonate species, with the latter being involved in the water gas shift side reaction. Surface science Ni-ZrO2 model catalysts were prepared by first growing an ultrathin "trilayer" (O-Zr-O) ZrO2 support on an Pd3Zr alloy substrate, and subsequently depositing Ni, with the process being monitored by XPS and LEED. Apart from the trilayer oxide, there is a small fraction of ZrO2 clusters with more bulk-like properties. When CO was adsorbed on the (fully metallic) Ni particles at pressures up to 100 mbar, both PM-IRAS and XPS indicated CO dissociation around room temperature and blocking of the Ni surface by carbon (note that on the partially oxidized technological Ni particles, CO dissociation was absent). The Ni nanoparticles were stable up to 550 K but annealing to higher temperatures induced Ni migration through the ultrathin ZrO2 support into the Pd3Zr alloy. Both approaches have their benefits and limitations but enable us to address specific questions on a molecular level.

The Reactivity of Surface Active Carbonaceous Species with CO2 and Its Role on Hydrocarbon Conversion Reactions

Effect of support texture properties on Ni-Fe/γ-Al_2O_3 catalyst structure and catalytic performance for CO methanation

The deposition of coke from methane on a Ni/MgAl2O4 catalyst

Carbon deposition on catalyst during partial oxidation and reforming of CH4/C3H8 with CO2 to syngas

Activation of CO and Surface Carbon Species for Conversion of Syngas to Light Olefins on ZnCrO -Al2o3 Catalysts

Meso-porous Ni/Mg/Al catalysts for methane reforming with CO2

Dynamic Oxygen on Surface: Catalytic Intermediate and Coking Barrier in the Modeled Co2 Reforming of Ch4 on Ni (111)

Carbon Deposition on Meso-Porous Al2o3 Supported Ni Catalysts in Methane Reforming with Co2

Studies on carbon deposition of Ni catalyst in CH4-CO2 reforming reaction

Research Progress of Carbon Deposition on Ni-Based Catalyst for CO2-CH4 Reforming

Revealing the Effect of Nickel Particle Size on Carbon Formation Type in the Methane Decomposition Reaction

Insight into Carbon Deposition Associated with NiCo/MgO Catalyzed CH4/CO2 Reforming by Using Density Functional Theory

Tuning reverse water gas shift and methanation reactions during CO2 reduction on Ni catalysts via surface modification by MoOx

Mesoscale study of crystal plane effects of Ni catalysts on CO2 hydrogenation

Deactivation of Ni Catalysts During Methane Autothermal Reforming with CO2 and O2 in a Fluidized-Bed Reactor

Surface Spectroscopy on UHV-Grown and Technological Ni-ZrO2 Reforming Catalysts: From UHV to Operando Conditions

Cobalt-doped Ni-based catalysts for low-temperature CO 2 methanation

Influence of Supports on Catalytic Behavior of Nickel Catalysts in Carbon Dioxide Reforming of Toluene As a Model Compound of Tar from Biomass Gasification.

Deciphering the Stability Mechanism of Pt-Ni/Al2O3 Catalysts in Syngas Production Via DRM

Facile preparation of a Ni/MgAl2O4 catalyst with high surface area: enhancement in activity and stability for CO methanation

Mechanistic and microkinetic insights into the stability and activity of Ni 3 In catalyst for dry methane reforming