Abstract:A series of gamma-Al2O3 samples modified with borate, phosphate, and sulfate were prepared by the impregnation technique and physically mixed with a methanol synthesis component (CuO-ZnO-Al2O3) at a mass ratio of 1 :2 to form hybrid catalysts. The direct synthesis of dimethyl ether (DME) from syngas was carried out over the prepared hybrid catalysts under pressurized fixed-bed continuous flow conditions. The results indicated that the modification of gamma-Al2O3 with SO42- could significantly enhance the activity for methanol dehydration and hence remarkably increase the selectivity for DME and the conversion of CO. The effects SO42- content, calcination temperature, and type of SO42- precursor on the performance of the SO42-/gamma-Al2O3 hybrid catalyst were further investigated. The results revealed that the selectivity for methanol decreased when the content 4 increased from 5% to 10%, resulting in the increase in both the selectivity for DME and the conversion of CO. However, when the SO42- content was further increased to 15 %, although the activity for methanol dehydration was increased continuously, the selectivity for DME decreased slightly due to the increased formation of byproducts hydrocarbons and CO2. Moreover, when the calcination temperature of SO42-/gamma-Al2O3 increased from 350 to 550 degrees C, both the CO conversion and the DME selectivity increased gradually, resulting from the decreased formation Of CO2. Nevertheless, a further increase in calcination temperature of SO42-/gamma-Al2O3 to 750 degrees C resulted in a significant decline in both DME selectivity and CO conversion because of the decreased activity for methanol dehydration. On the other hand, the type of SO42- precursors exerted no noticeable influence on the performance of the prepared hybrid catalysts.

Modification of Alumina and Its Application in the Direct Synthesis of Dimethyl Ether from Syngas

The Direct Synthesis of Dimethyl Ether from Syngas over Hybrid Catalysts with Sulfate-Modified Γ-Alumina As Methanol Dehydration Components

99/00320 Effect of oxide dispersion in a bifunctional catalyst on the formation of dimethyl ether

THE DIRECT SYNTHESIS OF DIMETHYL ETHER FROM SYNGAS OVER THE HYBRID CATALYST WITH ANTIMONY MODIFIED HZSM-5 ZEOLITE AS ACID COMPONENT

Promoted catalytic performance of sugarcane bagasse ash supported by γ‐alumina as efficient, stable, and ecofriendly catalyst for dehydration of methanol to dimethyl ether

Influence of SiO2/Al2O3 ratio in HMCM-22 on catalytic performance of Cu2ZnO2Al2O3/HMCM-22 for synthesis of dimethyl ether

Highly Efficient Synthesis of Dimethyl Ether from Syngas over the Admixed Catalyst of CuO–ZnO–Al2O3 and Antimony Oxide Modified HZSM-5 Zeolite

Ta 2 O 5 Modified Γ-Al 2 O 3 As a Methanol Dehydration Component in the Single-Step Synthesis of Dimethyl Ether from Syngas

Surface acidity and the dehydration of methanol to dimethyl ether

Effect of Si Content on the Performance of Direct Synthesis of Dimethyl Ether over Slurry CuZnAl Catalyst Prepared by Complete Liquid Phase Technology

Aluminum Fluoride Modified HZSM-5 Zeolite with Superior Performance in Synthesis of Dimethyl Ether from Methanol

Effects of Ammonium Hexafluorosilicate Modification on Acidity of Hmcm-22 and Catalytic Performance of Cuo-Zno-Al2o3/Hmcm-22 for Dimethyl Ether Synthesis

Influence of SiO_2/Al_2O_3 Ratio in HMCM-22 on Catalytic Performance of Cu-ZnO-Al_2O_3/HMCM-22 for Synthesis of Dimethyl Ether

Cu–Mn–Al based catalyst for the direct syngas to dimethyl ether conversion

Enhancement of the dimethyl ether carbonylation activation via regulating acid sites distribution in FER zeolite framework

Optimizing CO 2 Hydrogenation to DME through Tailored Interfacial Interactions: Weakening Synergy in CuZnZr and Al-Modified SBA-15 Catalysts

Dme Synthesis From Co/H-2 Over Cu-Mn/Gamma-Al2o3 Catalyst

The facile preparation of Cu–Zn–Al oxide composite catalysts with high stability and performance for the production of dimethyl ether using modified aluminum alkoxide

Acidity of Magnesium Oxide Modified HZSM-5 Zeolite and Its Application in the Direct Synthesis of Dimethyl Ether from Syngas--The Effect of Magnesium Precursor

Preparation of Phosphorus-Modified Hzsm-5 Zeolite and Its Application in the One-Step Synthesis of Dimethyl Ether from Syngas

Research on Si–Al Based Catalysts Prepared by Complete Liquid-Phase Method for DME Synthesis in a Slurry Reactor