Abstract:Premixed Charge Compression Ignition (PCCI) is a combustion concept that holds the promise of combining emission levels of a spark-ignition engine with the efficiency of a compression-ignition engine. In a short term scenario, PCCI would be used in the lower load operating range only, combined with conventional diesel combustion at higher loads. This scenario relies on using near standard components and conventional fuels; therefore a set of fuels is selected that only reflects short term changes in diesel fuel composition. Experiments have been conducted in one dedicated test cylinder of a modified 6-cylinder 12.6 liter heavy duty DAF engine. This test cylinder is equipped with a stand-alone fuel injection system, EGR circuit and air compressor. For the low load operating range the compression ratio has been lowered to 12:1 by means of a thicker head gasket. It is shown that emission levels and performance strongly correlate with the combustion delay (CD=CA50-SOI), independent of how this combustion delay is achieved. In a longer term scenario, both engine hardware and fuels can be adapted to overcome intrinsic PCCI challenges. At higher loads and at 15:1 compression ratio, necessary for good full load efficiency, a less reactive fuel is required to delay auto-ignition and phase combustion correctly. A number of low reactivity fuel blends have been used to investigate the desired Cetane Number for PCCI operation at different loads. For these blends too, all emission levels as well as the efficiency are shown to greatly correlate with the combustion delay. With an improved efficiency because of the higher compression ratio, the blend with an estimated CN of 25 was found to be the most flexible in being able to choose the optimum CD for the conditions and load used.

Experimental Study on Combustion Characteristics of a Diesel PCCI Engine

Combustion and Emission Characteristics of a DME (dimethyl Ether)-Diesel Dual Fuel Premixed Charge Compression Ignition Engine with EGR (exhaust Gas Recirculation)

Effect of DME Premixed Ratio and Diesel Injection Advanced Angle on PCCI Engine Performance

Experiment on CCCI Combustion in a Engine Fueled with DME

Influence of Premixed Charge Compression Ignition and Direct Injection Combustion on Engine Performance

Study on Combustion Characteristics of Partial Premixed Charge Compression Ignition-Direct Injection Engine Fueled with Dimethyl Ether

Investigation on Effects of Cold EGR on Combustion and Emission Characteristics in a DME PCCI-DI Engine

Experimental Research on PCCI-DI Combustion by Guiding Intake Air with DME Premixing

Study on Cycle-by-cycle Variations in a Diesel Engine with Dimethyl Ether As Port Premixing Fuel

Dimethyl ether energy ratio effects in a dimethyl ether-diesel dual fuel premixed charge compression ignition engine

Numerical Simulation Investigation on Effect of the Different Parameters on the Combustion Pressure and Temperature in a PCCI-DI Engine

An Experimental Investigation of Optimizing Control of Compound Charge Compression Ignition(CCCI)Combustion in an Engine Fueled with DME

Experimental Study of Fuel Composition Impact on PCCI Combustion in a Heavy-Duty Diesel Engine

Evaluation on the Effects of Compression Ratio, CO2 and LPG on HCCI Combustion Fueled with DME

Evaluation on Effects of Compression Ratio on DME HCCI Combustion Experiments

Combustion and Emission Characteristics of a Diesel Engine with DME As Port Premixing Fuel under Different Injection Timing

Advanced combustion operation in a single-cylinder engine

Effects of DME Pilot Quantity on the Performance of a DME PCCI-DI Engine

Particulate Size Distribution from Diesel–Dimethyl Ether Dual Fuel Premixed Compression Ignition Combustion Engine

Study on combustion and emission of a dimethyl ether-diesel dual-fuel premixed charge compression ignition combustion engine with LPG (liquefied petroleum gas) as ignition inhibitor

Experimental study of effects of exhaust gas recirculation and combustion mode on combustion, emission, and performance of DME‐methanol ‐fueled turbocharged c ommon‐rail engine