Abstract:Vented methane deflagrations in a 1 m3 vessel were investigated.Double flame acceleration phenomena were observed.CFD software FLACS was validated against experimental data.The mechanisms of the external overpressure peaks were revealed.The location of the external explosion was determined.This paper experimentally investigated the effect of low vent burst pressure on the overpressure buildup and flame evolution during the vented methane-air deflagrations in a 1 m3 rectangular vessel. CFD software FLACS was assessed in simulation of vented methane-air explosions against the experiment. Experimental results demonstrate that four overpressure peaks of Popen, Pout, Pext and Pacc from the vent failure, flame venting, external explosion and acoustically enhanced combustion, respectively, were observed except for the free venting case, in which only two overpressure peaks of Pout and Pext were monitored. The flame behaviors corresponding to different overpressure peaks were monitored especially at Pacc, where an abrupt increase in flame luminosity was observed on the bottom of the vessel due to the combustion of pockets of flammable mixture. Popen and Pacc increase with the vent burst pressure while Pout and Pext are nearly independent of the vent burst pressure. Double flame accelerations were observed owing to the vent rupture and flame venting. The phenomena of Helmholtz oscillation and the bulk motion of flame bubble always appeared after the vent rupture. The predicted overpressure agrees reasonably well with the experimental data. The discrepancy of the predicted and measured maximum peak overpressures reduces with increasing vent burst pressure. The predicted maximum peak overpressure and external flame length are slightly larger than those in experiment, which would facilitate the safe design in explosion venting and offer a better guidance in risk assessment. The simulation results also show that two overpressure peaks were recorded resulting from the pressure wave propagating above the vessel and the external explosion, respectively.

Effect of different vent covers on the overpressure and flame propagation characteristics of hydrocarbon fuel-air mixture venting explosion

Experimental and numerical study on the effect of low vent burst pressure on vented methane-air deflagrations

The overpressure and temperature characteristics of hydrogen-air mixtures during a vented explosion in a large L/D ratio duct: Effect of burst pressure

Effects of methane volume fractions and vent areas on dynamic characteristics of vented methane-air explosion in a half-open duct

Effects of vent layout and vent area on dynamic characteristics of premixed methane-air explosion in a tube with two side-vented ducts

Experimental investigation on the effect of vent film material and thickness and hydrogen fraction on explosion-venting features of H2/CO/Air mixtures within a horizontal duct

Effects of ignition location, obstacles, and vent location on the vented hydrogen-air deflagrations with low vent burst pressure in a 20-foot container

Effect of vent area on the vented methane-air deflagrations in a 1 m3 rectangular vessel with and without obstacles

Effect of burst pressure and vented area on vented hydrogen explosions

Insight into vented explosion mechanism and premixed flame dynamics in linked vessels: Influence of membrane thickness and blocking rate

Influence of vent size and vent burst pressure on vented ethylene-air explosion: Experimental and numerical study

Explosion Load Characteristics of Fuel—Air Mixture in a Vented Chamber: Analysis and New Insights

Study on the Influence of Vent Shape and Blockage Ratio on the Premixed Gas Explosion in the Chamber with a Small Aspect Ratio.

Experimental study on external explosion for vented hydrogen deflagration in a rectangular tube with different vent coefficients

Experimental study on the effects of ignition location and vent burst pressure on vented hydrogen-air deflagrations in a cubic vessel

Shock Wave Dynamics and Venting Overpressure Hazards Induced by Indoor Premixed Hydrogen/air Explosion

Experimental study on the flame-dual field overpressure coupling evolution characteristics of LPG/DME blended gas explosion venting

Investigation on the Flame and Pressure Behaviors of Vented Hydrogen-Air Deflagration from a Duct-Connected Vessel: Effects of Venting Diameter and Static Activation Pressure

Explosion venting hazards of temperature effects and pressure characteristics for premixed hydrogen-air mixtures in a spherical container

Effect Analysis of the Venting Direction on Explosion Pressure in LPG Pipelines

Investigation on the characteristics of vented stoichiometric methane-air explosion: Effect of ignition positions and obstacles