Abstract:Anaerobic digestion (AD) produces useful biogas and waste streams with high levels of dissolved methane (CH4) and ammonium (NH4+), among other nutrients. Membrane biofilm reactors (MBfRs), which support dissolved methane oxidation in the same reactor as simultaneous nitrification and denitrification (ME-SND), are a potential bubble-less treatment method. Here, we demonstrate ME-SND taking place in single-stage, AD digestate liquid-fed MBfRs, where oxygen (O2) and supplemental CH4 were delivered via pressurized membranes. The effects of two O2 pressures, leading to different O2 fluxes, on CH4 and N removal were examined. MBfRs achieved up to 98% and 67% CH4 and N removal efficiencies, respectively. The maximum N removal rates ranged from 57 to 94 mg N L-1 d-1, with higher overall rates observed in reactors with lower O2 pressures. The higher-O2-flux condition showed NO2- as a partial nitrification endpoint, with a lower total N removal rate due to low N2 gas production compared to lower-O2-pressure reactors, which favored complete nitrification and denitrification. Membrane biofilm 16S rRNA amplicon sequencing showed an abundance of aerobic methanotrophs (especially Methylobacter, Methylomonas, and Methylotenera) and enrichment of nitrifiers (especially Nitrosomonas and Nitrospira) and anammox bacteria (especially Ca. Annamoxoglobus and Ca. Brocadia) in high-O2 and low-O2 reactors, respectively. Supplementation of the influent with nitrite supported evidence that anammox bacteria in the low-O2 condition were nitrite-limited. This work highlights coupling of aerobic methanotrophy and nitrogen removal in AD digestate-fed reactors, demonstrating the potential application of ME-SND in MBfRs for the treatment of AD's residual liquids and wastewater. Sensor-based tuning of membrane O2 pressure holds promise for the optimization of bubble-less treatment of excess CH4 and NH4+ in wastewater.

Synchronous improvement of methane production and digestate dewaterability in sludge anaerobic digestion by nanobubble

Enhanced Production of Methane from Waste Activated Sludge by Pretreatment Using a Gas Diffusion Cathode

Improving methane productivity of waste activated sludge by ultrasound and alkali pretreatment in microbial electrolysis cell and anaerobic digestion coupled system

Effects of nano-bubble water on anaerobic co-digestion of cabbage waste and cow manure under mesophilic and thermophilic conditions

Nanobubble technology to enhance energy recovery from anaerobic digestion of organic solid wastes: Potential mechanisms and recent advancements

Supplementation of CO2-nanobubble water to enhance the methane production from anaerobic digestion of corn straw

Nanobubble water promotes anaerobic digestion of high-solids cattle manure under mesophilic and thermophilic conditions

Alleviation of volatile fatty acids inhibition in anaerobic digestion of swine manure with nano-bubble water supplementation

Metagenomic analysis reveals metabolic mechanism of enhancing lignocellulosic anaerobic digestion mediated by CO2/O2-nanobubble water

Enhancement of methane production from anaerobic co-digestion of food waste and dewatered sludge by thermal, ultrasonic and alkaline technologies integrated with protease pretreatment

Enhanced waste activated sludge digestion using a submerged anaerobic dynamic membrane bioreactor: performance, sludge characteristics and microbial community

Effect of nanobubble water on anaerobic methane production from lignin

Simultaneous addition of CO2-nanobubble water and iron nanoparticles to enhance methane production from anaerobic digestion of corn straw

Performance and microbial community analysis of anaerobic sludge digestion enhanced by in-situ microaeration

Enhanced two-phase anaerobic digestion of waste activated sludge by combined free nitrous acid and manganese dioxide

Effect of Pre-Treatments on Biological Methane Potential of Dewatered Sewage Sludge under Dry Anaerobic Digestion.

Treatment of Anaerobic Digester Liquids via Membrane Biofilm Reactors: Simultaneous Aerobic Methanotrophy and Nitrogen Removal

Simultaneous dissolved methane and nitrogen removal from low-strength wastewater using anaerobic granule-based sequencing batch reactor

Development of aerobic methane oxidation, denitrification coupled to methanogenesis (AMODM) in a microaerophilic expanded granular sludge blanket biofilm reactor

Ultrasonication as anaerobic digestion pretreatment to improve sewage sludge methane production: Performance and microbial characterization

A novel additive for enhancing biomass energy production from agro-industrial wastes: synthesis of hydrophobic nanoporous silica aerogel and its effect on methane production